2 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
This equipment is a relatively complicated apparatus.
During installation, operation maintenance or service,
individuals may be exposed to certain components or
conditions including, but not limited to: refrigerants,
materials under pressure, rotating components, and
both high and low voltage. Each of these items has the
potential, if misused or handled improperly, to cause
bodily injury or death. It is the obligation and responsibility
of operating/service personnel to identify and
recognize these inherent hazards, protect themselves,
and proceed safely in completing their tasks. Failure
to comply with any of these requirements could result
in serious damage to the equipment and the property in
IMPORTANT!
READ BEFORE PROCEEDING!
GENERAL SAFETY GUIDELINES
which it is situated, as well as severe personal injury or
death to themselves and people at the site.
This document is intended for use by owner-authorized
operating/service personnel. It is expected that this individual
posseses independent training that will enable
them to perform their assigned tasks properly and safely.
It is essential that, prior to performing any task on
this equipment, this individual shall have read and understood
this document and any referenced materials.
This individual shall also be familiar with and comply
with all applicable governmental standards and regulations
pertaining to the task in question.
SAFETY SYMBOLS
The following symbols are used in this document to alert the reader to specific situations:
Indicates a possible hazardous situation
which will result in death or serious injury
if proper care is not taken.
Indicates a potentially hazardous situation
which will result in possible injuries
or damage to equipment if proper care is
not taken.
Identifies a hazard which could lead to
damage to the machine, damage to other
equipment and/or environmental pollution
if proper care is not taken or instructions
and are not followed.
Highlights additional information useful
to the technician in completing the work
being performed properly.
External wiring, unless specified as an optional connection in the manufacturer’s product line, is
not to be connected inside the OptiView cabinet. Devices such as relays, switches, transducers and
controls and any external wiring must not be installed inside the micro panel. All wiring must be in
accordance with Johnson Controls’ published specifications and must be performed only by a qualified
electrician. Johnson Controls will NOT be responsible for damage/problems resulting from improper
connections to the controls or application of improper control signals. Failure to follow this warning
will void the manufacturer’s warranty and cause serious damage to property or personal injury.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 3
CHANGEABILITY OF THIS DOCUMENT
In complying with Johnson Controls’ policy for continuous
product improvement, the information contained
in this document is subject to change without notice.
Johnson Controls makes no commitment to update or
provide current information automatically to the manual
owner. Updated manuals, if applicable, can be obtained
by contacting the nearest Johnson Controls Service
office or accessing the Johnson Controls QuickLIT
website at http://cgproducts.johnsoncontrols.com.
Operating/service personnel maintain responsibility for
the applicability of these documents to the equipment.
If there is any question regarding the applicability of
these documents, the technician should verify whether
the equipment has been modified and if current literature
is available from the owner of the equipment prior
to performing any work on the chiller.
CHANGE BARS
Revisions made to this document are indicated with a
line along the left or right hand column in the area the
revision was made. These revisions are to technical information
and any other changes in spelling, grammar
or formatting are not included.
MANUAL DESCRIPTION FORM NUMBER
Variable Speed Drive – Operation 160.00-O1
Solid State Starter – Operation and Maintenance 160.00-O2
Floor Mounted MV SSS – Operation 160.00-O5
Unit Mounted MV SSS – Operation 160.00-O7
Installation – Unit 160.75-N1
Optiview™ Control Center – Operation and Maintenance 160.54-O1
Wiring Diagram – Field Connections for YK Chiller (Style G) OptiView Control Center with Remote Low
or Medium Voltage EMS or Unit Mounted Low or Medium Voltage SSS 160.75-PW1
Wiring Diagram – Field Connections for YK Chiller (Style G) OptiView Control Center with Remote
Medium Voltage SSS 160.75-PW2
Wiring Diagram – Field Connections for YK Chiller (Style G) OptiView Control Center with Remote
Medium Voltage VSD 160.75-PW3
Wiring Diagram – Field Control Modifications for YK Chiller (Style G) 160.75-PW4
Wiring Diagram – YK Chiller (Style G) OptiView Control Center with Remote Low or Medium Voltage EMS 160.75-PW5
Wiring Diagram – YK Chiller (Style G) OptiView Control Center with Unit Mounted Low or Medium
Voltage SSS, Unit Mounted Low Voltage VSD with Modbus, or Remote Medium Voltage VSD 160.75-PW6
Wiring Diagram – YK Chiller (Style G) OptiView Control Center with LTC I/O Board with Remote Low or
Medium Voltage EMS 160.75-PW7
Wiring Diagram – YK Chiller (Style G) OptiView Control Center w/ LTC I/O Board with Unit Mounted Low
or Medium Voltage SSS, Unit Mounted Low Voltage VSD with Modbus or Remote Medium Voltage VSD 160.75-PW8
Renewal Parts – Unit 160.75-RP1
Renewal Parts – OptiView Control Center 160.54-RP1
4 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
TABLE OF CONTENTS
TABLE 1 - Unit Components (Q3-Q6 Compressors) ................................................................................................6
TABLE 2 - Unit Piping (Q3-Q7 Compressors) ...........................................................................................................8
TABLE 3 - Oil Pump Housing (Q3-Q7 Compressors) .............................................................................................12
TABLE 4 - Unit Components (Q7, P7-P9 & H9 Compressors) ...............................................................................14
TABLE 5 - Unit Piping (Q7, P7-P9 & H9) ................................................................................................................16
TABLE 6 - Oil Pump Housing (P7-P9 & H9) ...........................................................................................................20
TABLE 7 - Unit Components (K1-K4 & K7) .............................................................................................................22
TABLE 8 - Unit Piping (K1-K4 & K7) .......................................................................................................................26
TABLE 9 - Oil Pump Housing (K1-K4 & K7) ...........................................................................................................30
TABLE 10 - Oil Filter Arrangements ........................................................................................................................32
TABLE 11 - 2" Variable Orifice (Q3-Q7 & P7) .........................................................................................................34
TABLE 12 - Variable Orifice 2" Falling Film (Q3-Q7 & P7) ......................................................................................36
TABLE 13 - Variable Orifice 2" Heat Recovery (Q4 & Q7) ......................................................................................38
TABLE 14 - Variable Orifice 2" (P8 & P9) ...............................................................................................................40
TABLE 15 - Variable Orifice 3" (P8, P9 & H9) .........................................................................................................41
TABLE 16 - Variable Orifice 3" (P8 & P9 Falling Film) ............................................................................................42
TABLE 17 - Varibale Orifice 3" (H9 Falling Film) .....................................................................................................44
TABLE 18 - Variable Orifice 3" (K1, K2 & K2 Heat Recovery) ................................................................................46
TABLE 19 - Variable Orifice 4" (K1-K3 & K2 Heat Recovery) .................................................................................48
TABLE 20 - Variable Orifice 4" (K3 & K4) ...............................................................................................................50
TABLE 21 - Variable Orifice 5" (K4, K7 & K7 Heat Recovery) ................................................................................52
TABLE 22 - Evaporator Relief Valves .....................................................................................................................54
TABLE 23 - Condenser Relief Valves .....................................................................................................................55
TABLE 24 - 2" Hot Gas Bypass ..............................................................................................................................57
TABLE 25 - 3" Hot Gas Bypass ..............................................................................................................................58
TABLE 26 - 4" Hot Gas Bypass ..............................................................................................................................59
TABLE 27 - PRV Position Sensor Kit (371-02012-001) ..........................................................................................60
TABLE 28 - Variable Speed Oil Pump Panel (NEMA 1) ..........................................................................................62
TABLE 29 - Variable Speed Oil Pump Panel (NEMA 4/12 & NEMA4X) .................................................................64
TABLE 30 - Variable Speed Oil Pump Control PAnel (CE) .....................................................................................66
TABLE 31 - System Control Components ...............................................................................................................68
TABLE 32 - Motor Monitoring..................................................................................................................................70
TABLE 33 - 3/4" Evaporator Tubes (Flooded Shell)................................................................................................72
TABLE 34 - 1" Evaporator Tubes (Flooded Shell)...................................................................................................77
TABLE 35 - 3/4" Evaporator Tubes (Hybrid Falling Film-Flooded Shell).................................................................78
TABLE 36 - 1" Evaporator Tubes (Hybrid Falling Film-Flooded Shell)....................................................................80
TABLE 37 - 3/4" Condenser Tubes .........................................................................................................................82
TABLE 38 - 3/4" Heat Recovery Condenser Tubes ................................................................................................86
TABLE 39 - 1" Condenser Tubes ............................................................................................................................88
TABLE 40 - 1" Heat Recovery Condenser Tubes ...................................................................................................89
TABLE 41 - Condenser Compact Waterboxes 150 PSI ..........................................................................................90
TABLE 42 - Condenser Compact Waterboxes 150 PSI (Prior July 2010) ..............................................................92
TABLE 43 - Evaporator With Standard Compact Waterboxes 150 PSI ..................................................................94
TABLE 44 - Evaporator With Standard Compact Waterboxes 300 PSI ..................................................................96
TABLE 45 - Condenser With Marine Waterboxes 150 PSI .....................................................................................98
TABLE 46 - Condenser With Marine Waterboxes 300 PSI ...................................................................................100
TABLE 47 - Evaporator With Marine Waterboxes 150 PSI ...................................................................................102
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 5
TABLE OF CONTENTS (CONT'D)
TABLE 48 - Evaporator With Marine Waterboxes 300 PSI ...................................................................................104
TABLE 49 - Condenser With Heat Recovery Compact Waterboxes 150 PSI .......................................................106
TABLE 50 - Condenser With Heat Recovery Compact Waterboxes 300 PSI .......................................................107
TABLE 51 - Condenser With Heat Recovery Marine Waterboxes 150 PSI ..........................................................108
TABLE 52 - Neoprene Vibration Isolators .............................................................................................................109
TABLE 53 - Spring Isolators..................................................................................................................................109
TABLE 54 - Inlet Chilled Water Strainer (Compact Heads and Marine Waterboxes) ........................................... 110
TABLE 55 - Current Transformer Kit and Transformer Only ................................................................................. 110
TABLE 56 - Multiple Unit Sequence Kit (Two Unit) ............................................................................................... 111
TABLE 57 - Multiple Unit Sequence Kit (Three Unit) ............................................................................................ 111
TABLE 58 - Multiple Unit Sequence Kit (Four Unit) .............................................................................................. 111
TABLE 59 - Consumables..................................................................................................................................... 112
TABLE 60 - Flow Switch Control ........................................................................................................................... 112
TABLE 61 - Differential Pressure Control ............................................................................................................. 112
TABLE 62 - Temperature Recorder ....................................................................................................................... 112
TABLE 63 - Common Piping Parts ........................................................................................................................ 112
TABLE 64 - Electrical Connectors ......................................................................................................................... 113
TABLE 65 - Recommended Spares ..................................................................................................................... 113
TABLE 66 - Autogreeser Kit .................................................................................................................................. 113
6 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Q3 - Q6 COMPRESSORS
UNIT COMPONENTS
Table 1 - UNIT COMPONENTS (Q3-Q6 COMPRESSORS)
ITEM DESCRIPTION PART NUMBER QUANTITY FIGURE
4 Gasket, ANSI 10-150# Garock (Q3/Q4) 028-15075-014 1
1
Gasket, ANSI 12-150# Garlock (Q5/Q6/Q7) 028-15075-015 1
7 O-ring, Neoprene 2.6 Id .210 Thk (2" Flange) 028-14469-000 1 *
8 O-ring, Neoprene 3.1 Id .210 Thk (2-1/2" Flange) 028-12597-000 1 *
15 Valve, Butterfly Size 5" (Q3/Q4) 022-10641-005 1
1
Valve, Butterfly Size 6" (Q5/Q6) 022-10641-006 1
16 Gasket, ANSI 5-150# Garlock (Q3/Q4) 028-15075-011 1
1
Gasket, ANSI 6-150# Garlock (Q5/Q6/Q7) 028-15075-012 1
24 Gasket (Q3/Q4) 028-15129-301 1
1
Gasket (Q5/Q6/Q7) 028-15129-302 1
30 Stud, Conts Thd 3/4-10 x 3-1/2 021-12772-000 8 1
33 Bottle, High Density 028-10579-000 1 1
34 Cap, High Density Bottle 066-89574-000 1 1
35 O-ring, Neoprene 5.975 Id .210 Thk (Q3/Q4) 028-14482-000 1
1
O-ring, Neoprene 7.475 Id .210 Thk (Q5/Q6/Q7) 028-15061-000 1
NOTE: Items with an * are NOT represented.
If the Discharge Spool Assembly
is stamped with a "G" on the
flanges it requires two gaskets
(item 16).
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 7
LD08501
Q3 - Q6 COMPRESSORS
UNIT COMPONENTS
Figure 1 - UNIT COMPONENTS (Q3-Q6 COMPRESSORS)
8 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Q3 - Q7 COMPRESSORS
UNIT PIPING
Table 2 - UNIT PIPING (Q3-Q7 COMPRESSORS)
ITEM DESCRIPTION PART NUMBER QUANTITY FIGURE
5 Solenoid, Valve 3/8 ORFS 025-35150-001 1
2
5A Coil, Service Replacement 025-37841-001 1
6 Cooler, Oil 026-37549-000 1 2/4
7 Valve, Thermal Expansion 025-35133-000 1
2
7A O-ring, Neoprene .489ID .070THK 028-12961-013 1
8 Elbow, 3/4 OD Tube Male 023-18291-000 1 2
9 Elbow, 1" OD Tube 90° Male 023-18292-000 2 3/4
13 Hose, Refrig. ORFS 3/4 x 28 026-39123-028 1 3
17 Elbow, 3/8 OD x .035 x 8-12 023-18990-000 3 4
23 Gasket, Flare 3/8 OD Tube 028-01258-000 2 2/3
24 Cap, Flare 3/8 OD Tube 023-00977-000 2 2
26 O-ring, Neoprene .489 ID .070 Thk 028-12961-013 1 *
27 O-ring, Neoprene .924 Id .116 Thk 028-12961-006 1 2
30 Coupling, Sld C x C 3/4 x 1/2 023-16299-000 1 2
31 O-ring, Neoprene .739 Id .070 Thk 028-12961-015 7 2/3/4
32 O-ring, Neoprene .926 Id 0.70 Thk 028-12961-016 2 4
43 Transducer, Pressure 025-28678-006 3 2/3
44 Transducer, Pressure 025-28678-112 1 3
46 Connr, 3/8 OD Tube Male 023-18976-000 1 *
47
Fitting, 3/8 x 3/8 OD Tube Male 023-23701-000 1
Fitting, 3/4 x 3/8 OD Tube Male (Q3/Q4 after 2/2010) 023-25118-000 1 3
Connector, 3/8 OD Tube Male (Q3-Q7 after 12/2011) 023-25551-000 1
53 Valve, Ball 3/4 ID x 3/4 OD M 022-11685-000 1 2
55 Bottle, High Density 028-10579-000 1 *
58 Valve, Stop Angle Vertical 022-09577-000 3 3
59 O-ring, Neoprene .351 Id .072 Thk 028-12961-001 3 3
154 Filter, Drier 3/8 ORFS 026-37563-000 1 2
164 O-ring, Neoprene .414 Id x .072 Thk 028-12961-002 3 2/3
165 O-ring, Neoprene .364 Id x .070 Thk 028-12961-012 11 2/3/4
166 O-ring, Neoprene .468 Id x .078 Thk 028-12961-003 7 3/4
167 O-ring, Neoprene 1.17 Id x .116 Thk 028-12961-008 2 3/4
168 Drain Plug, Condenser 023-18282-000 1 *
169 O-ring, Drain Plug 028-12961-008 1 *
170 Sight Glass, Cond / Evap 023-17197-000 2 *
171 O-ring, Sight Glass 028-12961-036 2 *
172 Valve, Cond / Evap 022-09573-000 2 22
173 Gasket, Service Valve 028-04836-000 2 22
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 9
Q3 - Q7 COMPRESSORS
UNIT PIPING
Figure 2 - UNIT PIPING (Q3 - Q7 COMPRESSORS)
LD13061
10 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Figure 3 - UNIT PIPING (Q3 - Q7 COMPRESSORS)
LD13062
Q3 - Q7 COMPRESSORS
UNIT PIPING (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 11
Figure 4 - UNIT PIPING (Q3 - Q7 COMPRESSORS)
LD13063
Q3 - Q7 COMPRESSORS
UNIT PIPING (CONT'D)
12 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Q3 - Q7 COMPRESSORS
OIL PUMP HOUSING (Q3 - Q7 COMPRESSORS)
Table 3 - OIL PUMP HOUSING (Q3-Q7 COMPRESSORS)
ITEM DESCRIPTION PART NUMBER FIGURE
1
Body, Oil Pump Housing (Q3-Q4) (Complete) 375-72177-001
5
Body, Oil Pump Housing (Q3-Q4) (Canada) (Complete) 375-72178-000
Body, Oil Pump Housing (Q5-Q7) (Complete) 375-72193-001
Body, Oil Pump Housing (Q5-Q7) (Canada) (Complete) 375-72194-000
1A O-ring, Cover Plate (All) 028-11977-000
1B Cover Plate (Q3-Q7) 075-46360-000
1B Cover Plate (Q3-Q7 Canada) 075-54037-000
1C O-ring, Neoprene 2.600ID .210THK 028-14469-000
2 Pump, Oil 20 GPM YK (Q3/Q4 prior 7/2010) 026-37937-000
5
Pump, Oil 20 GPM YK (Q3/Q4 after 7/2010) 026-46326-002
4 Block, Oil Eductor Special K 026-37553-000 5
5 Heater, Electric Immer (1,000 W) 025-34523-000 5
6 Valve, Stop Angle Vertical 022-09578-000 5
7 Valve, Stop Angle Vertical 022-09577-000 5
8 Valve, Stop Angle Vertical 022-10054-000 5
9 Gage, Liquid Level Sight Front 026-37571-000 5
12 Sensor, Temp. 50,000 OHMS DIN 025-39993-000 5
13 Terminal, HV Fused Glass 025-32933-000 *
16 Baffle, Oil Pump Housing 092-07827-000 *
18 Screw, Cap Hex Soc Hd 3/8 021-08946-000 5
19 O-ring, Neoprene 01.734id .139 Thk 028-05188-000 5
20 O-ring, Neoprene 01.171id .116 Thk 028-12961-008 5
21 O-ring, Neoprene 0.924id .116 Thk 028-12961-006 5
23 O-ring, Neoprene 0.644id .087 Thk 028-12961-004 5
24 O-ring, Neoprene 0.468id 0.78 Thk 028-12961-003 5
25 O-ring, Neoprene 0.351id 0.772 Thk (Terminal) 028-12961-001 *
26 O-ring, Neoprene 0.612id .103 Thk 028-11999-000 5
27 O-ring, Neoprene 2.600id 0210 Thk 028-14469-000 5
28 O-ring, Neoprene 0.487id .103 Thk 028-12961-035 5
29 Box, Elec 4 Octagon x 4 Deep 025-33238-000
5
Box, Elec with Filter Board (after 11/2011) 025-45067-000
30 Cover, Filter Outout Assy. 375-26580-000 5
31 Screw, Mach Pan Head Recd 021-03741-000 5
33 Terminal, Push-on Str 14-10 (200-346) 025-09455-000 *
34 Terminal, Push-on Str 18-14 (380-416, 440-600) 025-25920-000 *
35 Strap, Cable T and B L7-50-9-M 025-09607-000 5
36 Cap, Sealing Caplug 250 028-04574-000 5
37 Insr, Elec 025-10371-000 5
38 Ferr, Splice Cap 025-10372-000 5
39 Valve, Stop Angle 022-10047-000 5
40 Plate, Oil Pump Mtg Machining (Canada) 075-54038-000 5
41 Pin, Slot Spg 3/16 x 1/2 (Canada) 029-04138-000 5
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 13
Figure 5 - OIL PUMP HOUSING ASSEMBLY (Q3 - Q7 COMPRESSORS)
LD13589
Q3 - Q7 COMPRESSORS
OIL PUMP HOUSING ASSEMBLY (Q3 - Q7 COMPRESSORS)
14 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Q7, P7 - P9, AND H9 COMPRESSORS
UNIT COMPONENTS
Table 4 - UNIT COMPONENTS (Q7, P7-P9 & H9 COMPRESSORS)
ITEM DESCRIPTION PART NUMBER QUANTITY FIGURE
4 Gasket, ANSI 12-150# (Q7 and P7) 028-15075-015 1
6
Gasket, 14-150# (P8, P9 and H9) 028-15075-016 1
7 O-ring, Neoprene 2.60 Id .21 Thk (2" Flange) 028-14469-000 1 *
8 O-ring, Neoprene 3.10 Id .21 Thk (2-1/2" Flange) 028-12597-000 1 *
15 Valve, Butterfly 6" (Q7 and P7) 022-10641-006 1
8
Valve, Butterfly 8" (P8, P9 and H9) 022-10641-008 1
16 Gasket, ANSI 6-150# (Q7 and P7) 028-15075-012 1
6
Gasket, ANSI 8-150# (P8, P9 and H9) 028-15075-013 1
24 Gasket (Q7 and P7) 028-15129-302 1
6
Gasket (P8, P9 and H9) 028-15129-303 1
35 O-ring, Neoprene 7.47 ID .210 Thk (Q7 and P7) 028-15061-000 1
6
O-ring, Neoprene 9.475 ID .210 Thk (P8, P9 and H9) 028-15319-000 1
NOTE: Items with an * are NOT represented.
If the Discharge Spool Assembly
is stamped with a "G" on the
flanges it requires two gaskets
(item 16).
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 15
Figure 6 - UNIT COMPONENTS (Q7, P7 - P9, AND H9 COMPRESSORS)
LD13169
Q7, P7 - P9, AND H9 COMPRESSORS
UNIT COMPONENTS
16 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Q7, P7 - P9 AND H9 COMPRESSORS
UNIT PIPING
Table 5 - UNIT PIPING (Q7, P7-P9 & H9)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
5 Valve, Solenoid 3/8 ORFS 025-35150-001 1 7
5A Coil, Service Replacement 025-37841-001 1 6
6
Cooler, Oil Special K (Q7) (P7, P8 and H9 Before 1-21-2008) 026-37549-000 1
Cooler, Oil Special K (P7 After 1-21-2008) 026-37909-000 1 7/9
Cooler, Oil Special K (P8, P9 and H9 After 1-21-2008) 026-41701-000 1
7 Valve, Thermal Expansion (Q7) 025-35133-000 1
7
Valve, Thermal Expansion (P7-P9 and H9) 025-38170-000 1
8 Connr, 3/4" OD Tube Male 023-20272-000 1 *
9 Elbow, 1" OD Tube 90° Male 023-18292-000 2 8
13 Hose, Refrig. ORFS 3/4" x 28 026-39123-028 1 7/8/9
14 Filter In-Line ORFS 023-20878-001 1 7
17 Elbow, 3/8" OD Tube 90° Male 023-18980-000 3 89
23 Gasket, Flare 3/8" OD Tube 028-01258-000 2 7/9
24 Cap, Flare 3/8" OD Tube 023-00977-000 2 7/8/9
26 O-ring, Neoprene .489 ID .070 THK 028-12961-013 1 7
27 O-ring, Neoprene .924 ID .116 THK 028-12961-006 1 7
30 Coupling, SLD C x C 3/4" x 1/2" 023-16299-000 1 7
31 O-ring, Neoprene .739 ID x .070 THK 028-12961-015 7 7/8/9
32 O-ring, Neoprene .926 ID x .070 THK 028-12961-016 2 8
43 Transducer, Pressure 025-28678-006 3 8
44 Transducer, Pressure 025-28678-112 1 8
47 Fitting, 3/8" OD Tube Male (prior 9/2011) 023-23701-000
1 8
Fitting, 3/8" OD Tube Male (after 9/2011) 023-25551-000
53 Valve, Ball 3/4" ID x 3/4" OD 022-11685-000 1 7
55 Bottle, High Density 028-10579-000 1 8
58 Valve, Stop Angle 022-09577-000 1 7
59 O-ring, Neoprene .351 OD x .072 THK 028-12961-001 1 7
60 Valve, Stop Angle 022-10054-000 1 6
154 Filter, Drier 3/8" ORFS 026-37563-000 1 7
162 Valve, Stop Angle 022-10054-000 1 7
164 O-ring, Neoprene .414 ID x .072 THK 028-12961-002 4 8
165 O-ring, Neoprene .364 ID x .070 THK 028-12961-012 10 7/8/9
166 O-ring, Neoprene .468 ID x .070 THK 028-12961-003 5 8/9
167 O-ring, Neoprene 1.17 ID x .116 THK 028-12961-008 5 7
168 Drain Plug, Condenser 023-18282-000 1 *
169 O-ring, Drain Plug 1.171ID .116TH 028-12961-008 1 *
170 Sight Glass, Cond./Evap 023-17197-000 2 *
171 O-ring, Sight Glass 2.090ID .118THK 028-12961-036 2 *
172 Valve, Service Cond./Evap 022-09573-000 2 22
173 Gasket, Service Valve 028-04836-000 2 22
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 17
Q7, P7 - P9 AND H9 COMPRESSORS
UNIT PIPING
Figure 7 - UNIT PIPING (Q7, P7 - P9 AND H9 COMPRESSORS)
LD13161a
OIL COOLER
PIPING
(H9, P8 and P9)
18 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Figure 8 - UNIT PIPING (Q7, P7 - P9 AND H9 COMPRESSORS)
LD13062
Q7, P7 - P9 AND H9 COMPRESSORS
UNIT PIPING (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 19
Q7, P7 - P9 AND H9 COMPRESSORS
UNIT PIPING (CONT'D)
Figure 9 - UNIT PIPING (Q7, P7 - P9 AND H9 COMPRESSORS)
LD13163
20 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
P7 - P9 AND H9 COMPRESSORS
OIL PUMP HOUSING (P7 - P9, AND H9 COMPRESSORS)
Table 6 - OIL PUMP HOUSING (P7-P9 & H9)
ITEM DESCRIPTION PART NUMBER FIGURE
1
Body, Oil Pump Housing (P7) (Complete) 375-72195-001
10
Body, Oil Pump Housing (P7) (Canada) (Complete) 375-72196-000
Body, Oil Pump Housing (P8 and P9) (Complete) 375-72197-001
Body, Oil Pump Housing (P8 and P9) (Canada) (Complete) 375-72198-000
Body, Oil Pump Housing (H9) (Complete) 375-72214-001
Body, Oil Pump Housing (H9) (Canada) (Complete) 375-72215-000
1A O-ring, Cover 13.475ID .275THK (All) 028-11977-000
1B Cover Plate (P7, P8, P9, and H9) 075-46360-000
1B Cover Plate (P7, P8, P9 and H9) (Canada) 075-54037-000
1C O-ring, Neoprene 3.100ID .210THK 028-12597-000
2 Pump, Oil 20 GPM YK (prior 6/2010) 026-37937-000
10
Pump, Oil 20 GPM YK (after 6/2010) 026-46326-002
4 Block ,Oil Eductor Special K 026-37553-000 10
5
Heater, Electric Immer (3,000 W) (200-346) 025-32909-000
10 Heater, Electric Immer (3,000 W) (380-416) 025-32917-000
Heater, Electric Immer (3,000 W) (440-480) 025-32918-000
Heater, Electric Immer (3,000 W) (500-600) 025-32920-000
6 Valve, Stop Angle Vertical 022-09578-000 10
7 Valve, Stop Angle Vertical 022-09577-000 10
8 Valve, Stop Angle Vertical 022-10054-000 10
9 Gage, Liquid Level Sight Front 026-37571-000 10
12 Sensor, Temp. 50,000 OHMS DIN 025-39993-000 10
13 Terminal, HV Fused Glass 025-32933-000 *
16 Baffle, Oil Pump Housing 092-09753-000 *
19 O-ring, Neoprene 2.33id .118 Thk 028-12961-010 10
20 O-ring, Neoprene 01.171id .116 Thk 028-12961-008 10
21 O-ring, Neoprene 0.924id .116 Thk 028-12961-006 10
23 O-ring, Neoprene 0.644id .087 Thk 028-12961-004 10
24 O-ring, Neoprene 0.468id 0.78 Thk 028-12961-003 10
25 O-ring, Neoprene 0.351id 0.772 Thk (Terminal) 028-12961-001 *
26 O-ring, Neoprene 0.612id .103 Thk 028-11999-000 10
27 O-ring, Neoprene 2.600id 0210 Thk 028-14469-000 10
28 O-ring, Neoprene 0.487id .103 Thk 028-12961-035 10
29 Box, Elec 4 Octagon x 4 Deep 025-33238-000 10
30 Cover, Filter Outout Assy. 375-26580-000 10
33 Terminal, Push-on Str 14-10 (200-346) 025-09455-000 *
34 Terminal, Push-on Str 18-14 (380-416, 440-600) 025-25920-000 *
35 Strap, Cable T and B L7-50-9-M 025-09607-000 10
37 Ferr, Splice Cap 025-10372-000 10
38 Cap, Sealing Caplug 250 028-04574-000 10
41 Valve, Stop Angle 022-10047-000 10
42 Plate, Oil Pump Mtg Machining (Canada) 075-54038-000 *
43 Pin, Slot Spg 3/16 x 1/2 (Canada) 029-04138-000 *
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 21
Figure 10 - OIL PUMP HOUSING ASSEMBLY (P7 - P9, H9 COMPRESSORS)
LD13590
P7 - P9 AND H9 COMPRESSORS (CONT'D)
OIL PUMP HOUSING (P7 - P9, AND H9 COMPRESSORS)
22 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
K1 - K4 AND K7 COMPRESSORS
UNIT COMPONENTS
Table 7 - UNIT COMPONENTS (K1-K4 & K7)
ITEM DESCRIPTION PART
NUMBER
QUANTITY/
UNIT FIGURE
4
Discharge Assy., 8" (K1 KTKP-K7K4 with Iso) 392-10333-019
1 12
Discharge Assy., 8" (K1 KTKP-K7K4 without Iso) 392-10333-020
Discharge Assy., 8" (K1 Heat Recovery I-K with Iso) 392-16399-019
Discharge Assy., 8" (K1 Heat Recovery I-K without Iso) 392-16399-020
Discharge Assy., 8" (K1 Heat Recovery MN-MN with Iso) 392-16399-017
Discharge Assy., 8" (K1 Heat Recovery MN-MN without Iso) 392-16399-018
Discharge Assy., 8" (K1/K2 Heat Recovery PQ-PQ with Iso) 392-16399-017
Discharge Assy., 8" (K1/K2 Heat Recovery PQ-PQ without Iso) 392-16399-018
Discharge Assy., 8" (K1/K2 MQMQ-Q4Q4 without Iso) 392-10333-018
Discharge Assy., 8" (K1/K2 MQMQ-Q4Q4 with Iso) 392-10333-017
Discharge Assy., 8" (K2 Heat Recovery PQ-PQ without Iso) 392-16399-018
Discharge Assy., 8" (K2 Heat Recovery PQ-PQ with Iso) 392-16399-017
Discharge Assy., 10" (K3 NPNQ-Q4Q4 without Iso, K4 S-V with Iso) 392-10354-003
Discharge Assy., 10" (K3 NPNQ-Q4Q4 with Iso) 392-10354-001
Discharge Assy., 10" (K3 RQRQ-R7R4 without Iso) 392-10354-004
Discharge Assy., 10" (K3 RQRQ-R7R4 with Iso) 392-10354-002
Discharge Assy., 8" (K3 Heat Recovery NQ-NQ without Iso) 392-16400-003
Discharge Assy., 8" (K3 Heat Recovery NQ-NQ with Iso) 392-16400-001
Discharge Assy., 20-3/8" (K4 RPRP-S7S7 without Iso) 392-10354-006
Discharge Assy., 17-13/16" (K4 RPRP-S7S7 with Iso) 392-10354-005
Discharge Assy., 10" (K4 S-V without Iso) 392-10354-007
Discharge Assy., 10" (K4 X-T without Iso) 392-10354-003
Discharge Assy., 10" (K4 X-T with Iso) 392-10354-009
Discharge Assy., 10" (K4 X-X without Iso) 392-10354-005
Discharge Assy., 10" (K4 X-X with Iso) 392-10354-010
Discharge Assy., 12" (K7 W-W with Iso) 392-10366-002
Discharge Assy., 12" (K7 W-W without Iso) 392-10366-001
Discharge Assy., 12" (K7 Z-Z with Iso) 392-10366-004
Discharge Assy., 12" (K7 Z-Z without Iso) 392-10366-003
Discharge Assy., 12" (K7 Z-Y with Iso) 392-10366-005
Discharge Assy., 12" (K7 Z-Y without Iso) 392-10366-006
5
Valve, Butterfly Size 8" (K1-K2) 022-10641-008
Valve, Butterfly Size 10" (K3-K4) 022-10641-010 1 12
Valve, Butterfly Size 12" (K7) 022-10641-012
8 Flange, Oil Drain (K1-K2) 075-70282-000
1 11
Flange, Oil Drain (K3-K4, K7) 075-52450-000
9 O-ring, Neoprene 3.10 Id .210 Thk 028-12597-000 1 11
10 O-ring, Neoprene 2.73 Id .139 Thk 028-13578-000 1 11
11
Hose, Braided Flex Metal 52" 026-35300-012
1 11 Hose, Braided Flex Metal 62" 026-35300-005
Hose, Braided Flex Metal 68" 026-35300-013
Hose, Braided Flex Metal 78" 026-35300-008
12 Mounting Assy., Adjustable Mount 375-29270-000 1 12
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 23
TABLE 7 (CONT'D) - UNIT COMPONENTS (K1-K4 & K7)
K1 - K4 AND K7 COMPRESSORS
UNIT COMPONENTS (CONT'D)
ITEM DESCRIPTION PART
NUMBER
QUANTITY/
UNIT FIGURE
13
Support, Control Panel Bracket 12-1/2" 075-64758-000
Support, Control Panel Bracket 9" 075-54589-000 2 12
Support, Control Panel Bracket 18-1/2" 075-76062-000
50
Gasket, ANSI 8-150# (K1-K2) 028-15075-013
Gasket, ANSI 10-150# K3-K4) 028-15075-014 1 12
Gasket, ANSI 12-150# (K7) 028-15075-115
51
Gasket. ANSI 16-150# (K1-K2) 028-15075-017
Gasket, ANSI 18-150# (K3-K4) 028-15075-018 1 11
Gasket, ANSI 20-150# (K7) 028-15075-119
52
Gasket (K1-K2) 028-15129-304
Gasket (K3-K4) 028-15129-305 1 11
Gasket (K7) 028-15129-106
61
O-ring, Neoprene 9.475 Id .210 Thk (K1-K2) 028-15319-000
O-ring, Neoprene 11.475 Id .275 Thk (K3-K4) 028-15801-000 1 12
O-ring, Neoprene 13.475 Id .275 Thk (K7) 028-11977-000
62
Hose, Braided Flex Metal, 45" (after 6/2011) 026-46828-001
1 12 Hose, Braided Flex Metal, 51" (after 6/2011) 026-46828-002
Hose, Braided Flex Metal, 57" (after 6/2011) 026-46828-003
Hose, Braided Flex Metal, 36" (after 6/2011) 026-46828-004
65 Gasket, Round ANSI 2.00-150# (K3) 02815075-006 1 12
66 O-ring, Neoprene 2.60 Id .210 Thk (K3) 028-14469-000 1 12
67 O-ring, Neoprene 2.234 Id .139 Thk (K3) 028-16598-000 1 12
24 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Figure 11 - UNIT COMPONENTS (K COMPRESSORS)
K1 - K4 AND K7 COMPRESSORS
UNIT COMPONENTS (CONT'D)
LD13059
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 25
50
5
61
4
12
67
65
66
13
62
Figure 12 - UNIT COMPONENTS (K COMPRESSORS)
LD13060
K1 - K4 AND K7 COMPRESSORS
UNIT COMPONENTS (CONT'D)
26 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
K1 - K4 AND K7 COMPRESSORS
UNIT PIPING
Table 8 - UNIT PIPING (K1-K4 & K7)
ITEM DESCRIPTION PART NUMBER QUANTITY FIGURE
2 Block, Oil Eductor (K1-K4) 026-37956-000
1 13/14
Block, Oil Eductor (K7) 026-46156-000
5 Valve, Solenoid 3/8" ORFS NC 025-35150-001 1
13/14
5A Coil, Service Replacement 025-37841-001 1
6 Oil Cooler 026-37958-000 1 13
7 Valve, Thermal Expansion 025-38170-000 1 13
8 Valve, Ball 1" IDF x 1" ODM 022-09797-000 1 13
9 Elbow, 3/4" OD Tube 90° Male 023-20272-000 1 13
13 Hose, Refrig. ORFS 3/4" x 25 026-39123-025 1 13
14 Valve, Stop Angle Vertical 022-10046-000 1 13/14
15 Filter, In-Line ORFS 023-20878-001 1 13
23 Gasket, Flare 3/8" OD Tube 028-01258-000 2 13
24 Cap, Flare 3/8" OD Tube 023-00977-000 2 13
27 O-ring, Neoprene .924 Id .116 Thk 028-12961-006 2 13/14
31 O-ring, Neoprene .739 Id .070 Thk 028-12961-015 11 13
32 O-ring, Neoprene .926 Id .070 Thk 028-12961-016 7 13
43 Transducer, Pressure 025-28678-006 3 13/14
44 Transducer, Pressure 025-28678-112 1 13
46 Connr, 3/8" OD Tube Male 023-18976-000 3 13
47 Connr, 1" OD Tube Male 023-18972-000 1 13
48 Elbow, Swivel Nut 3/8 023-21884-000 1 13
49 Fitting, 3/8" OD Tube Male (prior 12-2011) 023-23701-000
1 13/14
Connector, 3/8 OD Tube Male (after 12-2011) 023-25551-000
55 Bottle, High Density 028-10579-000 1 *
58 Valve, Stop Angle Vertical 022-09577-000 2 13
59 O-ring, Neoprene .351 ID .072 Thk 028-12961-001 2 13
61 Union, 3/4" 023-20731-000 1 13
62 Union, 1" 023-20223-000 1 13
63 Elbow, 1" OD Tube 90° Male 023-18292-000 1 13
153 Valve,Solenoid 3/8 ORFS 025-35150-002 1 13
154 Filter, Drier 3/8" ORFS 026-37563-000 1 13/14
164 O-ring, Neoprene .414 Id .072 Thk 028-12961-002 4 13/14
165 O-ring, Neoprene .364 Id .072 Thk 028-12961-012 10 13/14
166 O-ring, Neoprene .468 Id .078 Thk 028-12961-003 7 13/14
167 O-ring, Neoprene 1.17 Id .116 Thk 028-12961-008 2 13
176 Valve, Stop Angle Vertical 022-10054-000 3 13
180 Drain Plug, Cond. 023-18282-000 1 *
181 O-ring, Drain Plug 1.171ID .116THK 028-12961-008 1 *
182 Sight Glass, Cond./Evap. 023-17197-000 2 *
183 O-ring, Sight Glass 2.090ID .118THK 028-12961-036 2 *
184 Valve, Service Cond./Evap. 022-09573-000 2 22
185 Gasket, Service Valve 028-04836-000 2 22
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 27
Figure 13 - UNIT PIPING (K COMPRESSORS)
LD13064
K1 - K4 AND K7 COMPRESSORS
UNIT PIPING (CONT'D)
28 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Figure 14 - UNIT PIPING (K COMPRESSORS)
LD13065
K1 - K4 AND K7 COMPRESSORS
UNIT PIPING (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 29
THIS PAGE INTENTIONALLY LEFT BLANK.
30 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
K1 - K4 AND K7 COMPRESSORS
OIL PUMP HOUSING (K1 - K4 AND K7 COMPRESSORS)
Table 9 - OIL PUMP HOUSING (K1-K4 & K7)
ITEM DESCRIPTION PART NUMBER FIGURE
1 Body, Oil Pump Housing (K1-K4 and K7) 375-60694-000
15 Body, Oil Pump Housing (K1-K4 and K7) (Canada) 375-61444-000
1A O-ring, Cover 13.475ID .275THK (All) 028-11977-000
1B Cover Plate (K1-K7)(All) 075-46360-000
2 Pump, Oil 20 GPM YK (prior 6-2010) 026-37937-000
15
Pump, Oil 20 GPM YK (after 6-2010) 026-46326-002
5
Heater, Electric Immer (3,000 W) (200-346) 025-32909-000
15 Heater, Electric Immer (3,000 W) (380-416) 025-32917-000
Heater, Electric Immer (3,000 W) (440-480) 025-32918-000
Heater, Electric Immer (3,000 W) (550-600) 025-32920-000
6 Valve, Stop Angle Vertical 022-09578-000 15
7 Valve, Stop Angle Vertical 022-09577-000 15
8 Valve, Stop Angle Vertical 022-10047-000 15
9 Gage, Liquid Level Sight Front 026-37571-000 15
12 Sensor, Temp. 50,000 OHMS DIN 025-39993-000 15
13 Terminal, HV Fused Glass 025-32933-000 *
19 O-ring, Neoprene 2.33id .118 Thk 028-12961-010 15
20 O-ring, Neoprene 0.926id .070 Thk 028-12961-016 15
21 O-ring, Neoprene 0.924id .116 Thk 028-12961-006 15
23 O-ring, Neoprene 0.644id .087 Thk 028-12961-004 15
24 O-ring, Neoprene 0.468id 0.78 Thk 028-12961-003 15
25 O-ring, Neoprene 0.351id 0.772 Thk (Terminal) 028-12961-001 15
28 O-ring, Neoprene 0.487id .103 Thk 028-12961-035 15
29 Box, Elec 4 Octagon x 4 Deep 025-33238-000 15
30 Cover, Filter Outout Assy. 375-26580-000 15
31 Screw, Mach Pan Head Recd 021-03741-000 15
33 Terminal, Push-on Str 14-10 (200-346) 025-09455-000 *
34 Terminal, Push-on Str 18-14 (380-416, 440-600) 025-25920-000 *
35 Strap, Cable T and B L7-50-9-M 025-09607-000 15
36 Insr, Elec 025-10371-000 15
37 Ferr, Splice Cap 025-10372-000 15
38 Cap, Sealing Caplug 250 028-04574-000 15
39 O-Ring, Neoprene 1.171id .116 Thk 028-12961-008 15
42 Plate, Oil Pump Mtg Machining (Canada) 075-54038-000 15
43 Pin, Slot Spg 3/16 x 1/2 (Canada) 029-04138-000 15
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 31
Figure 15 - OIL PUMP HOUSING ASSEMBLY (K1 - K4, AND K7 COMPRESSORS)
LD13591
20
21
K1 - K4 AND K7 COMPRESSORS
OIL PUMP HOUSING (K1 - K4 AND K7 COMPRESSORS)
32 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
OIL FILTER ARRANGEMENTS
SINGLE AND DUAL FILTERS
Table 10 - OIL FILTER ARRANGEMENTS
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
SINGLE OIL FILTER
1 Filter, Oil 026-37589-000 1
16
Filer, Oil Hydac Housing 026-37589-001 1
1A Filter Element, Replacement 026-32831-000 1 *
1B O-ring, Filter Housing 3.484ID .139THK 028-14404-000 1 *
1 Filter, Oil Seubert Housing w/ 026-47427-000 1 16
2 Valve, Stop Angle Vertical 022-10092-000 1 16
3 Valve, Stop Angle Vertical 022-10046-000 2 16
4 Refrig. and Hose Assy. 3/4 x 17 026-39123-017 1 16
7 O-ring, Neoprene .351 ID .072 Thk 028-12961-001 1 16
8 O-ring, Neoprene .924 ID .116 thk 028-12961-006 2 16
9 O-ring, Neoprene .739 ID .070 thk 028-12961-015 1 16
10 Connr, 3/4 OD Tube Male 023-18290-000 1 16
DUAL OIL FILTERS
1 Filter, Oil 026-37589-000 2
16
Filer, Oil Hydac Housing 026-37589-001 2
1A Filter Element, Replacement 026-32831-000 2 *
1B O-ring, Filter Housing 3.484ID .139THK 028-14404-000 2 *
1 Filter, Oil Seubert Housing w/ 026-47427-000 2 16
2 Valve, Stop Angle Vertical 022-10092-000 2 16
3 Valve, Stop Angle Vertical 022-10046-000 2 16
7 O-ring, Neoprene .351 ID .072 THK 028-12961-001 2 16
8 O-ring, Neoprene .924 ID .116 THK 028-12961-006 5 16
9 O-ring, Neoprene .739 ID .070 thk 028-12961-015 6 16
10 Connr, 3/4 OD Tube Male 023-18290-000 1 16
18 Valve, 3-way Ball 022-10094-000 1 16
19 Tee, Union 3/4 023-18913-000 1 16
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 33
Figure 16 - OIL FILTER ARRANGEMENTS
LD12997
To Compressor
To Compressor
FROM OIL COOLER
FROM OIL COOLER
OIL FILTER ARRANGEMENTS
SINGLE AND DUAL FILTERS
34 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE ORIFICE
VARIABLE ORIFICE (Q3 - Q7 AND P7)
2" OPTION WITH ISOLATION VALVE
Table 11 - 2" VARIABLE ORIFICE (Q3-Q7 & P7)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
2 Gasket, 2" Valve 064-47078-000 1 17
3 Valve, Stop Compr. 2-5/8 OD 022-10048-000 1 17
4 HCS5, 0.625-11 x 4.5 GR 5 Zn 021-32010-036 8 17
5 Gasket, Flange 028-14463-000 1 17
7 HCS5, .625-11 x 2.5 GR5 Zn 021-32010-020 4 17
8 Valve, Butterfly Sz. 2" 022-10642-002 1
17
8A O-ring, Neoprene 3.109 ID .139Thk 028-12961-023 2
9 Nut, Hex .625-11 x GR 5 Zn 021-32010-501 4 17
13 Valve, Ball 1-1/16-12UN-2A 022-09757-000 1 17
14 O-ring, Neoprene .924 ID .116 Thk 028-12961-006 2 17
15 Valve, Stop Angle Vertical 022-12047-000 1 17
16 Sensor, Temperature 3000 Ohms 025-39517-000 1 17
17 Actuator, Electric 025-38177-000 1 *
2" OPTION WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
4 HCS5, 0.625-11 x 4.5 GR 5 Zn 021-32010-036 8 17
8 Valve, Butterfly Sz. 2" 022-10642-002 1
17
8A O-ring, Neoprene 3.109 ID .139Thk 028-12961-023 2
9 Nut, Hex .625-11 x GR 5 Zn 021-32010-501 4 17
13 Valve, Ball 1-1/16-12UN-2A 022-09757-000 1 17
14 O-ring, Neoprene .924 ID .116 Thk 028-12961-006 3 17
15 Valve, Stop Angle Vertical 022-12047-000 1 17
16 Sensor, Temperature 3000 Ohms 025-39517-000 1 17
17 Actuator, Electric 025-38177-000 1 *
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 35
A-A to D-D Shell Codes E-E to F-F Shell Codes
A-A to D-D Shell Codes E-E to F-F Shell Codes
Q3-Q7, P7
WITHOUT ISOLATION VALVE
Q3-Q7, P7
WITH ISOLATION VALVE
Figure 17 - VARIABLE ORIFICE (2") STANDARD YK
LD13044
36 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE ORIFICE (Q3 - Q7 AND P7) WITH FALLING FILM
2" OPTION WITH ISOLATION VALVE
Table 12 - VARIABLE ORIFICE 2" FALLING FILM (Q3-Q7 & P7)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
2 Gasket, 2" Valve 064-47078-000 1 18
3 Valve, Stop Compr. 2-5/8 OD 022-10048-000 1 18
4 HCS5, 0.625-11 x 4.5 GR 5 Zn 021-32010-036 8 18
5 Gasket, Flange 028-14463-000 1 18
7 HCS5, .625-11 x 2.5 GR5 Zn 021-32010-020 4 18
8 Valve, Butterfly Sz. 2" 022-10642-002 1
18
8A O-ring, Neoprene 3.109 ID .139Thk 028-12961-023 2
9 Nut, Hex .625-11 x GR 5 Zn 021-32010-501 4 18
14 O-ring, Neoprene .924 ID .116 Thk 028-12961-006 3 18
15 Valve, Stop Angle Vertical 022-12047-000 1 18
16 Sensor, Temperature 3000 Ohms 025-39517-000 1 18
17 Actuator, Electric 025-38177-000 1 *
2" OPTION WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
4 HCS5, 0.625-11 x 4.5 GR 5 Zn 021-32010-036 8 18
8 Valve, Butterfly Sz. 2" 022-10642-002 1
18
8A O-ring, Neoprene 3.109 ID .139Thk 028-12961-023 2
9 Nut, Hex .625-11 x GR 5 Zn 021-32010-501 4 18
13 Valve, Ball 1-1/16-12UN-2A 022-09757-000 1 18
14 O-ring, Neoprene .924 ID .116 Thk 028-12961-006 3 18
15 Valve, Stop Angle Vertical 022-12047-000 1 18
16 Sensor, Temperature 3000 Ohms 025-39517-000 1 18
17 Actuator, Electric 025-38177-000 1 *
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 37
A-A to F-F Shell Codes
A-A to F-F Shell Codes
TO EVAPORATOR
TO EVAPORATOR
FROM
CONDENSER
FROM
CONDENSER
Q3-Q7, P7
WITH ISOLATION VALVE
Q3-Q7, P7
WITHOUT ISOLATION VALVE
Figure 18 - VARIABLE ORIFICE (2") WITH FALLING FILM LD13044b
38 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE ORIFICE WITH HEAT RECOVERY (Q4 AND Q7)
2” OPTION WITH ISOLATION VALVE
Table 13 - VARIABLE ORIFICE 2" HEAT RECOVERY (Q4 & Q7)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
3 Valve, Ball S/W 022-08752-000 1 19
4 HCS5, 0.625-11 x 4.5 GR 5 Zn 021-32010-036 8 19
6 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 19
7 Plug, Hex HD 3/4 023-18280-000 1 19
8 Valve, Butterfly Sz. 2" 022-10642-002 1
19
8A O-ring, Neoprene 3.109 ID .139Thk 028-12961-023 2
9 Nut, Hex .625-11 x GR 5 Zn 021-32010-501 4 19
13 Valve, Ball 1-1/16-12UN-2A 022-09757-000 1 19
14 O-ring, Neoprene .924 ID .116 Thk 028-12961-006 3 19
15 Valve, Stop Angle Vertical 022-10047-000 1 19
16 Sensor, Temperature 3000 Ohms 025-39517-000 1 19
17 Actuator, Electric 025-38177-000 1 *
2” OPTION WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
4 HCS5, 0.625-11 x 4.5 GR 5 Zn 021-32010-036 8 19
6 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 19
7 Plug, Hex HD 3/4 023-18280-000 1 19
8 Valve, Butterfly Sz. 2" 022-10642-002 1
19
8A O-ring, Neoprene 3.109 ID .139 Thk 028-12961-023 2
9 Nut, Hex .625-11 x GR 5 Zn 021-32010-501 4 19
13 Valve, Ball 1-1/16-12UN-2A 022-09757-000 1 19
14 O-ring, Neoprene .924 ID .116 Thk 028-12961-006 3 19
15 Valve, Stop Angle Vertical 022-10047-000 1 19
16 Sensor, Temperature 3000 Ohms 025-39517-000 1 19
17 Actuator, Electric 025-38177-000 1 *
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 39
LD13044
Figure 19 - VARIABLE ORIFICE WITH HEAT RECOVERY (2")
Q3-Q7, P7
WITH ISOLATION VALVE
Q3-Q7, P7
WITHOUT ISOLATION VALVE
A-A to D-D Shell Codes E-E to F-F Shell Codes
A-A to D-D Shell Codes E-E to F-F Shell Codes
40 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE ORIFICE (P8 AND P9) STANDARD YK
2” OPTION WITH ISOLATION VALVE
Table 14 - VARIABLE ORIFICE 2" (P8 & P9)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Valve, Butterfly 150# 022-10642-002 1
20 1A O-ring, Neoprene 3.109 ID .139 Thk 028-12961-023 2
2 Valve, Ball S/W 2.00 022-08752-000 1 20
5 Valve, Ball Stor 1.06 022-09757-000 1 20
6 O-ring, Neoprene .924 Id 028-12961-006 2 20
12 Valve, Stop Ang Vertical 022-10047-000 1 20
14 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 20
15 Plug, Hex HD 3/4 023-18280-000 1 20
16 Sensor, Temperature 3000 Ohms 025-39517-000 1 20
17 Actuator, Electric 025-38177-000 1 *
2” OPTION WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Valve, Butterfly Size 2 022-10642-002 1
20 1A O-ring, Neoprene 3.109 ID .139 Thk 028-12961-023 2
5 Valve, Ball 1-1/16 - 12 Un-2a 022-09757-000 1 20
6 O-Ring, Neop 00.924id .116thk M 028-12961-006 2 20
12 Valve, Stop Ang Vertical 022-10047-000 1 20
14 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 20
15 Plug, Hex HD 3/4 023-18280-000 1 20
16 Sensor, Temperature 3000 Ohms 025-39517-000 1 20
17 Actuator, Electric 025-38177-000 1 *
NOTE: Items with an * are NOT represented.
6
12
1
1A
5
6
5
6
14
15
14
15
6
12
1
1A
2
F LD13046b igure 20 - VARIABLE ORIFICE (2")
WITH ISOLATION VALVE
WITHOUT ISOLATION VALVE
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 41
VARIABLE ORIFICE (P8, P9, H9 AND H9 WITH HEAT RECOVERY)
3” OPTION WITH ISOLATION VALVE
Table 15 - VARIABLE ORIFICE 3" (P8, P9 & H9)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
2 Valve, Butterfly #150 022-10642-002 1
21
2A O-ring, Neoprene 4.10 ID .210 Thk 028-12961-025 2
3 Valve, Ball S/W 2.00 022-08752-000 1 21
4 Gasket, ANSI 3-150# 028-15075-108 1 21
5 Valve, Ball 022-09757-000 1 21
6 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 21
7 Plug, Hex HD 3/4 023-18280-000 1 21
11 Actuator, Electric 025-38178-000 1 *
12 Valve, Stop Angle 022-10047-000 1 21
13 O-ring 028-12961-006 2 21
15 O-ring 028-12961-003 1 21
3” OPTION WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
2 Valve, Butterfly #150 022-10642-002 1
21
2A O-ring, Neoprene 4.10 ID .210 Thk 028-12961-025 2
5 Valve, Ball 022-09757-000 1 21
6 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 21
7 Plug, Hex HD 3/4 023-18280-000 1 21
11 Actuator, Electric 025-38178-000 1 *
12 Valve, Stop Angle 022-10047-000 1 21
13 O-ring 028-12961-006 2 21
15 O-ring 028-12961-003 1 21
NOTE: Items with an * are NOT represented.
12
13
7
6
3
2
2
4
5
13
5
13
12
13
7
6
LD13821
Figure 21 - VARIABLE ORIFICE (3")
WITH ISOLATION VALVE
WITHOUT ISOLATION VALVE
42 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE ORIFICE (P8 AND P9 WITH FALLING FILM)
3” OPTION WITH ISOLATION VALVE
Table 16 - VARIABLE ORIFICE 3" (P8 & P9 FALLING FILM)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Tee Liquid 3 X 3 X 3 375-76015-001 1 22
2 Valve Butterfly Size 3 022-10642-003 1 22
3 Valve Ball 3" Flanged 022-09739-000 1 22
4 Flange Rd Rf 150# S/O 3.00" 023-03610-000 2 22
5 Flange Rd Rf 150#Wn Std 3.00" 023-04436-000 2 22
12 Valve Stop Ang Vertical 022-12047-000 1 22
13 O-Ring Neo1 00.924id .116thk M 028-12961-006 1 22
14 Valve Stop Ang Vertical 022-10092-000 1 22
15 O-Ring Neo1 00.351id .072thk M 028-12961-001 1 22
19 Gasket, Round ANSI 3-150# 028-15075-008 1 *
3” OPTION WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Tee Liquid 3 X 3 X 3 375-76015-003 1 22
2 Valve Butterfly Size 3 022-10642-003 1 22
4 Flange Rd Rf 150# S/O 3.00" 023-03610-000 2 22
5 Flange Rd Rf 150#Wn Std 3.00" 023-04436-000 2 22
12 Valve Stop Ang Vertical 022-12047-000 1 22
13 O-Ring Neo1 00.924id .116thk M 028-12961-006 1 22
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 43
LD13821a
Figure 22 - VARIABLE ORIFICE (3") WITH FALLING FILM
FROM
CONDENSER
TO
EVAPORATOR
P8 and P9
WITHOUT ISOLATION VALVE
P8 and P9
WITH ISOLATION VALVE
4
3
12, 13
5
1
FROM
CONDENSER
TO
EVAPORATOR
1 14, 15
2 2
4
12, 13
4
5
44 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE ORIFICE (H9 WITH FALLING FILM)
3” OPTION WITH ISOLATION VALVE
Table 17 - VARIBALE ORIFICE 3" (H9 FALLING FILM)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Tee Liquid 3 X 3 X 3 375-76015-001 1 23
2 Valve Butterfly Size 3 022-10642-003 1 23
3 Valve Ball 3" Flanged 022-09739-000 1 23
4 Flange Rd Rf 150# S/O 3.00" 023-03610-000 2 23
5 Flange Rd Rf 150#Wn Std 3.00" 023-04436-000 2 23
11 Valve Stop Ang Vertical 022-12047-000 1 23
12 O-Ring Neo1 00.924id .116thk M 028-12961-006 1 23
13 Valve Stop Ang Vertical 022-10092-000 1 23
14 O-Ring Neo1 00.351id .072thk M 028-12961-001 1 23
19 Gasket, Round ANSI 3-150# 028-15075-008 1 *
3” OPTION WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Tee Liquid 3 X 3 X 3 375-76015-003 1 23
2 Valve Butterfly Size 3 022-10642-003 1 23
4 Flange Rd Rf 150# S/O 3.00" 023-03610-000 2 23
5 Flange Rd Rf 150#Wn Std 3.00" 023-04436-000 2 23
11 Valve Stop Ang Vertical 022-12047-000 1 23
12 O-Ring Neo1 00.924id .116thk M 028-12961-006 1 23
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 45
VARIABLE ORIFICE (H9 WITH FALLING FILM)
3” OPTION WITH ISOLATION VALVE
5
2
H9 with Isolation H9 without Isolation LD17742
11
12 11
12
4
3
5
5
2
2
4
5
2
1 13
14
1
Figure 23 - VARIABLE ORIFICE (3")
46 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE ORIFICE (K1, K2 AND K2 WITH HEAT RECOVERY)
3” OPTION WITH ISOLATION VALVE
Table 18 - VARIABLE ORIFICE 3" (K1, K2 & K2 HEAT RECOVERY)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
2 Valve, Butterfly 3" 022-10642-003 1
24
2A O-ring, Neoprene 4.10 ID .210 Thk 028-12961-025 2
3 Valve, Ball 3" Flanged 022-09739-000 1 24
4 Gasket, ANSI 3-150# 028-15075-108 1 24
6 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 24
7 Plug, Hex HD 3/4 023-18280-000 1 24
11 Actuator, Electric 025-38178-000 1 *
12 Valve, Stop Angle 022-10047-000 1 24
13 O-ring, Neoprene .924ID .116THK 028-12961-006 2 24
14 Plug, Hex 023-18962-000 1 24
15 O-ring, Neoprene .468ID .078THK 028-12961-003 1 24
16 Valve Ball 1 Npti X 1 Npti 022-06873-000 1 24
17 Bush Pipe 1 - 11-1/2 Npte 023-04045-000 1 24
18 Connr 3/4 Ext Fla X 3/4 023-00934-000 1 24
19 Gasket Fla 3/4 Od Tube 028-09211-000 1 24
3” OPTION WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
2 Valve, Butterfly 3" 022-10642-003 1
24
2A O-ring, Neoprene 4.10 ID .210 Thk 028-12961-025 2
6 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 24
7 Plug, Hex HD 3/4 023-18280-000 1 24
11 Actuator, Electric 025-38178-000 1 *
12 Valve, Stop Angle 022-10047-000 1 24
13 O-ring, Neoprene .924ID .116THK 028-12961-006 2 24
14 Plug, Hex 023-18962-000 1 24
15 O-ring, Neoprene .468ID .078THK 028-12961-003 1 24
16 Valve Ball 1 Npti X 1 Npti 022-06873-000 1 24
17 Bush Pipe 1 - 11-1/2 Npte 023-04045-000 1 24
18 Connr 3/4 Ext Fla X 3/4 023-00934-000 1 24
19 Gasket Fla 3/4 Od Tube 028-09211-000 1 24
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 47
WITHOUT ISOLATION VALVE
K1 and K2
WITH ISOLATION VALVE
LD13822
Figure 24 - VARIABLE ORIFICE (3")
48 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE ORIFICE (K1 - K3 AND K2 WITH HEAT RECOVERY)
4” OPTION WITH ISOLATION VALVE
Table 19 - VARIABLE ORIFICE 4" (K1-K3 & K2 HEAT RECOVERY)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
2 Valve, Butterfly 4" 022-10642-004 1
25
2A O-ring, Neoprene 5.10 ID 2.75 Thk 028-12961-026 2
3 Valve, Ball 4" Flanged 022-09740-000 1 25
4 Gasket, ANSI 4-150# 028-15075-110 1 25
5 Plug, Hex 023-18962-000 1 25
6 O-ring, Neoprene .644 ID .087 028-12961-004 1 25
7 Plug, Hex HD 3/4 023-18280-000 1 25
8 HCS5, .625-11 x 3 GR5 Zn 021-32010-024 8 25
9 HSC5, .625-11 x 5 GR5 Zn 021-32010-040 8 25
10 Nut, Hex .625-11 GR5 Zn 021-32010-501 16 25
11 Actuator, Electric 025-38178-000 1 *
12 Valve, Stop Angle 022-10047-000 1 25
13 O-ring, Neoprene .924ID .116THK 028-12961-006 1 25
14 Valve, Stop Angle 022-10054-000 1 25
15 O-ring, Neoprene .468ID .078THK 028-12961-003 1 25
16 Valve, Ball 1 Npti X 1 Npti 022-06873-000 1 25
17 Bush, Pipe 1 - 11-1/2 Npte 023-04045-000 1 25
18 Connr, 3/4 Ext Fla X 3/4 023-00934-000 1 25
19 Gasket, Fla 3/4 Od Tube 028-09211-000 1 25
4” OPTION WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
2 Valve, Butterfly 4" 022-10642-004 1
25
2A O-ring, Neoprene 5.10 Id .275 Thk 028-12961-026 2
5 Plug, Hex 023-18962-000 1 25
6 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 25
7 Plug, Hex HD 3/4 023-18280-000 1 25
9 HCS5, .625-11 GR5 Zn 021-32010-040 8 25
10 Nut, Hex .625-11 GR5 Zn 021-32010-501 8 25
11 Actuator, Electric 025-38178-000 1 *
12 Valve, Stop Angle 022-10047-000 1 25
13 O-ring, Neoprene .924ID .116THK 028-12961-006 1 25
14 Valve, Stop Angle 022-10054-000 1 25
15 O-ring, Neoprene .468ID .078THK 028-12961-003 1 25
16 Valve, Ball 1 Npti X 1 Npti 022-06873-000 1 25
17 Bush, Pipe 1 - 11-1/2 Npte 023-04045-000 1 25
18 Connr, 3/4 Ext Fla X 3/4 023-00934-000 1 25
19 Gasket, Fla 3/4 Od Tube 028-09211-000 1 25
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 49
WITHOUT ISOLATION VALVE
WITH ISOLATION VALVE
K1-K3
Figure 25 - VARIABLE ORIFICE (4")
LD13046
50 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE ORIFICE (K3 AND K4)
4” OPTION WITH ISOLATION VALVE
Table 20 - VARIABLE ORIFICE 4" (K3 & K4)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
2 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 26
3 Plug, Hex HD 3/4 023-18280-000 1 26
4 Valve, Butterfly SZ 4" 022-10642-004 1
26
4A O-ring, Neoprene 5.10 ID .275 Thk 028-12961-026 2
8 Pipe, 16" Lg 4" Sch 40 075-67789-000 1 26
9 HCS5, .625-11 x 3 GR5 Zn 021-32010-024 16 26
10 Nut, Hex .625-11 x GR5 Zn 021-32010-501 24 26
11 HCS5, .625-11 x 5 GR5 Zn 021-32010-040 8 26
12 Actuator, Electric 025-38178-000 1 *
13 Valve, Stop Angle 022-10047-000 1 26
14 O-ring, Neoprene .924ID .116THK 028-12961-006 1 26
15 Valve, Stop Angle 022-10054-000 1 26
16 O-ring, Neoprene .468ID .078THK 028-12961-003 1 26
17 Valve, Ball 1 Npti X 1 Npti 022-06873-000 1 26
18 Bush, Pipe 1 - 11-1/2 Npte 023-04045-000 1 26
19 Connr, 3/4 Ext Fla X 3/4 023-00934-000 1 26
20 Gasket, Fla 3/4 Od Tube 028-09211-000 1 26
4” OPTION WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
2 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 26
3 Plug, Hex HD 3/4 023-18280-000 1 26
4 Valve, Butterfly, Sz 4" 022-10642-004 1
26
4A O-ring, Neoprene 5.10 ID .275 Thk 028-12961-026 2
8 Gasket, ANSI 4-150# 028-15075-110 1 26
9 HCS5, .625-11 x GR5 Zn 021-32010-024 8 26
10 Nut, Hex .625-11 GR5 Zn 021-32010-501 16 26
11 HCS5, .625-111 x 5 GR5 Zn 021-32010-040 8 26
12 Actuator, Electric 025-38178-000 1 *
13 Valve, Stop Angle 022-10047-000 1 26
14 O-ring, Neoprene .924ID .116THK 028-12961-006 1 26
15 Valve, Stop Angle 022-10054-000 1 26
16 O-ring, Neoprene .468ID .078THK 028-12961-003 1 26
17 Valve, Ball 1 Npti X 1 Npti 022-06873-000 1 26
18 Bush, Pipe 1 - 11-1/2 Npte 023-04045-000 1 26
19 Connr, 3/4 Ext Fla X 3/4 023-00934-000 1 26
20 Gasket, Fla 3/4 Od Tube 028-09211-000 1 26
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 51
WITHOUT ISOLATION VALVE
WITH ISOLATION VALVE
K3 and K4
Figure 26 - VARIABLE ORIFICE (4")
LD13047
52 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE ORIFICE (K4, K7 AND K7 WITH HEAT RECOVERY)
5” OPTION WITH ISOLATION VALVE
Table 21 - VARIABLE ORIFICE 5" (K4, K7 & K7 HEAT RECOVERY)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
2 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 27
3 Plug, Hex HD 3/4 023-18280-000 1 27
4 Valve, Butterfly SZ 5" 022-10642-005 1
27
4A O-ring, Neoprene 5.975 ID .275 Thk 028-12961-027 2
8 Gasket, ANSI 6-150# 028-15075-112 2 27
9 Valve, Ball 6" Flanged 022-10609-000 1 27
11 HCS5, .75-10 x 3 GR5 Zn 021-32012-024 16 27
12 Nut, Hex .750-10 x 5 GR5 Zn 032-32012-501 24 27
13 HCS5, .75-10 x 5 GR5 Zn 021-32012-040 8 27
14 Actuator, Electric 025-38178-000 2 *
15 Valve, Stop Angle 022-10047-000 1 27
16 O-ring, Neoprene .924ID .116THK 028-12961-006 1 27
17 Valve, Stop Angle 022-10054-000 1 *
18 O-ring, Neoprene .468ID .078THK 028-12961-003 1 *
19 Valve, Ball 1 Npti X 1 Npti 022-06873-000 1 27
20 Bush, Pipe 1 - 11-1/2 Npte 023-04045-000 1 27
21 Connr, 3/4 Ext Fla X 3/4 023-00934-000 1 27
22 Gasket, Fla 3/4 Od Tube 028-09211-000 1 27
5” OPTION WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
2 O-ring, Neoprene .644 ID .087 THK 028-12961-004 1 27
3 Plug, Hex HD 3/4 023-18280-000 1 27
4 Valve, Butterfly, Sz 5" 022-10642-005 1
27
4A O-ring, Neoprene 5.975 ID .275 Thk 028-12961-027 2
9 Gasket, ANSI 6-150# 028-15075-112 1 27
10 HCS5, .75-10 x 3 GR5 Zn 021-32012-024 8 27
11 Nut, Hex .750-10 x GR5 Zn 032-32012-501 16 27
12 HCS5, .750-10 x 5 GR5 Zn 021-32012-040 8 27
13 Actuator, Electric 025-38178-000 2 *
15 Valve, Stop Angle 022-10047-000 1 27
16 O-ring, Neoprene .924ID .116THK 028-12961-006 1 27
17 Valve, Stop Angle 022-10054-000 1 27
18 O-ring, Neoprene .468ID .078THK 028-12961-003 1 27
19 Valve, Ball 1 Npti X 1 Npti 022-06873-000 1 27
20 Bush, Pipe 1 - 11-1/2 Npte 023-04045-000 1 27
21 Connr, 3/4 Ext Fla X 3/4 023-00934-000 1 27
22 Gasket, Fla 3/4 Od Tube 028-09211-000 1 27
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 53
WITHOUT ISOLATION VALVE
K6 and K7
WITH ISOLATION VALVE
Figure 27 - VARIABLE ORIFICE (5")
LD13048
54 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
RELIEF VALVES
Table 22 - EVAPORATOR RELIEF VALVES
EVAPORATOR WITHOUT ISOLATION VALVE
SHELL
CODE 3-WAY VALVE QUANTITY O-RING RELIEF VALVE QUANTITY O-RING FIGURE
A 022-10073-000 1 028-12961-008 022-10078-000 2 028-12961-008 28
C
022-10074-000 1 028-12961-017 022-10079-000 2 028-12961-017 28
D
E
F
G
H
I
J
K 022-10074-000 2 028-12961-017 022-10076-000 4 028-12961-017 28
L 022-10073-000 2 028-12961-008 022-10078-000 4 028-12961-008 28
M
022-10074-000 2 028-12961-017 022-10076-000 4 028-12961-017 28
N
P
Q
R
S
W 022-07892-003 1 - 022-07893-025* 2 - 28
X 022-10074-000 2 02-12961-017 022-10076-000 4 028-12961-017 28
Z 022-07892-003 1 - 022-07893-025* 2 - 28
NOTE: * Relief Valves require Pipe Bushing (023-05791-000).
EVAPORATOR WITH ISOLATION VALVE
SHELL
CODE RELIEF VALVE QUANTITY O-RING FIGURE
A 022-10078-000 1 028-12961-008 28
C
022-10079-000 1 028-12961-017 28
D
E
F
G
H
I
J
K 022-10076-000 2 028-12961-017 28
L 022-10078-000 2 028-12961-008 28
M
022-10076-000 2 028-12961-017 28
N
P
Q
R
S
W 022-07893-025** 1 - 28
X 022-10076-000 2 028-12961-017 28
Z 022-07893-025** 1 - 28
NOTE: ** Relief Valves require Flange Relief Valve Companion (023-13837-003).
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 55
RELIEF VALVES (CONT'D)
Table 23 - CONDENSER RELIEF VALVES
CONDENSER
SHELL
CODE 3-WAY VALVE QUANTITY O-RING RELIEF VALVE QUANTITY O-RING FIGURE
A
C 022-10073-000 1 028-12961-008 022-10078-000 2 028-12961-008 28
D
B*
022-10074-000 1 028-12961-017 022-10079-000 2 028-12961-017 28
E
F
I*
J
K
L
M
N
O*
P
Q
R 022-10074-000 2 028-12961-017 022-10076-000 4 028-12961-017 28
U*
S 1-5/8
022-10074-000
1-5/16
022-10073-000
2
1
028-12961-017
1-5/8
022-10079-000
1-5/16
022-10078-000
4
2
028-12961-017 28 T
V
W
022-100074-000 2 028-12961-017 022-10079-000 4 028-129-61-017 28
Y*
X 1-5/8
022-10074-000
1-5/16
022-10073-000
1
1
028-12961-017
1-5/8
022-10079-000
1-5/16
022-10078-000
2
2
028-12961-017 28
Z
NOTE: * = Heat Recovery
MISCELLANEOUS VALVES
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
172 Valve, Service Cond / Evap 022-09573-000 2 *
173 Gasket, Service Valve 028-04836-000 2 *
NOTE: Items with an * are NOT represented.
56 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
RELIEF VALVES (CONT'D)
Figure 28 - RELIEF VALVES
LD13049a
RELIEF
VALVE
RELIEF
VALVE
RELIEF
VALVE
RELIEF
VALVE
RELIEF
VALVE
3-WAY
VALVE
RELIEF
VALVE
RELIEF
VALVE
RELIEF
VALVE
RELIEF
VALVE
0-RING
0-RING
0-RING
0-RING
0-RING
0-RING
0-RING
0-RING
CONDENSER
EVAPORATOR
BUSHING
GASKET
GASKET
SERVICE
VALVE
SERVICE
VALVE
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 57
HOT GAS BYPASS COMPONENTS
2” WITH ISOLATION VALVE
Table 24 - 2" HOT GAS BYPASS
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Valve, Butterfly 2" 022-10643-002 1
29
1A O-ring, Neoprene 3.109 ID .139 Thk 028-12961-023 2
5 Valve, Stop Compr. 2-5/8 OD 022-10048-000 1 29
7 HCS5, .625-11 x 4.5 GR5 Zn 021-32010-036 8 29
8 HCS5, .625-11 x 2.5 GR5 Zn 021-32010-020 4 29
9 Nut, Hex .625-11 x GR5 Zn 021-32010-501 4 29
10 Gasket, Flange 2" Valve 064-47078-000 1 29
11 Gasket, 2" Valve 064-47078-000 1 29
13 Motor, Actuator 025-38180-000 1 *
14 Kit, PRV Position Sensor 371-02012-001 1 32
2” WITHOUT ISOLATION VALVE
ITEM
NUMBER DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Valve, Butterfly 2" 022-10643-002 1
29
1A O-ring, Neoprene 3.109 ID .139 Thk 028-12961-023 2
7 HCS5, .625-11 x 4.5 GR5 Zn 021-32010-036 4 29
9 Nut, Hex .625-11 x GR5 Zn 021-32010-501 4 29
10 Motor, Actuator 025-38180-000 1 *
11 Kit, PRV Position Sensor 371-02012-001 1 32
NOTE: Items with an * are NOT represented.
Figure 29 - HOT GAS BYPASS (2")
LD13050
WITH ISOLATION VALVE
WITHOUT ISOLATION VALVE
58 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
HOT GAS BYPASS COMPONENTS
3” WITH ISOLATION VALVE
Table 25 - 3" HOT GAS BYPASS
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Valve, Butterfly 3" 022-10643-003 1
30
1A O-ring, Neoprene 4.10 ID .210 Thk 028-12961-025 2
5 Valve, Ball 3" Flanged 022-09739-000 1 30
6 Gasket, ANSI 3-150# 028-15075-008 1 30
7 HCS5, .625-11 x 4.75 GR5 Zn 021-32010-038 4 30
8 HCS5, .625-11 x 3 GR5 Zn 021-32010-024 4 30
9 Nut, Hex .625-11 GR5 Zn 021-32010-501 8 30
10 Motor, Actuator 025-38180-000 1 *
11 Kit, PRV Position Sensor 371-02012-001 1 32
3” WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Valve, Butterfly 3" 022-10643-003 1
30
1A O-ring, Neoprene 4.10 ID .210 Thk 028-12961-025 2
7 HCS5, .625-11 x 4.75 GR5 Zn 021-32010-038 4 30
9 Nut, Hex .625-11 x GR5 Zn 021-32010-501 4 30
10 Motor, Actuator 025-38180-000 1 *
11 Kit, PRV Position Sensor 371-02012-001 1 32
NOTE: Items with an * are NOT represented.
LD13051 Figure 30 - HOT GAS BYPASS (3")
WITH ISOLATION VALVE
WITHOUT ISOLATION VALVE
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 59
HOT GAS BYPASS COMPONENTS
4” WITH ISOLATION VALVE
Table 26 - 4" HOT GAS BYPASS
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Valve, Butterfly 4" 022-10643-004 1
31
1A O-ring, Neoprene 5.10 ID .275 Thk 028-12961-026 2
5 Valve, Ball 4" Flanged 022-09740-000 1 31
6 Gasket, ANSI 4-150# 028-15075-010 1 31
7 HCS5 .625-11 x 4.75 GR5 Zn 021-32010-038 8 31
8 HCS5 .625-11 x 3.00 GR5 Zn 021-32010-024 8 31
9 Nut, Hex .625-11 x GR5 Zn 021-32010-501 16 31
10 Motor, Actuator 025-38180-000 1 *
11 Kit, PRV Position Sensor 371-02012-001 1 32
4” WITHOUT ISOLATION VALVE
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Valve, Butterfly 4" 022-10643-004 1
31
1A O-ring, Neoprene 5.10 ID .275 Thk 028-12961-026 2
7 HCs5, .625-11 x 4.75 GR5 Zn 021-32010-038 8 31
9 Nut, Hex .625-11 x GR5 Zn 021-32010-501 8 31
10 Motor, Actuator 025-38180-000 1 *
11 Kit, PRV Position Sensor 371-02012-001 1 32
NOTE: Items with an * are NOT represented.
LD13052
Figure 31 - HOT GAS BYPASS (4")
WITH ISOLATION VALVE
WITHOUT ISOLATION VALVE
60 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
PRV POSITION SENSOR KIT (371-02012-001)
Table 27 - PRV POSITION SENSOR KIT (371-02012-001)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Cover, PRV Position Sensor 071-02012-002 1 32
2 Bracket, Suppport Upper PRV 371-02012-209 1 32
3 Screw, Tapping Thread Forming 021-13757-000 2 32
4 POT, 2500 Ohms 2 Watt 025-32570-000 1 32
5 Bushing, Strain Relief Straight 025-09080-000 1 32
6 Cable PRV Sensor VSD 571-02012-005 1 32
7 Coupling, Shaft, Flexible 029-24196-000 1 32
8 Screw, Cap Hex Soc Hd #10 021-18674-000 2 32
9 Lockwasher, Hel Spg #10 032-08292-000 2 32
10 Strap, Cable T and B L4-18-9-M 025-18167-000 1 32
11 Cap, PRV Sensor 071-02012-006 1 32
12 Shaft, PRV Position Sensor 071-02012-007 1 32
13 Screw, Washer Assy. 021-18487-000 2 32
Figure 32 - PRV POSITION SENSOR KIT
LD13053
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 61
THIS PAGE INTENTIONALLY LEFT BLANK.
62 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE SPEED OIL PUMP CONTROL PANEL
NEMA 1 COMMON PARTS (371-04137-010)
Table 28 - VARIABLE SPEED OIL PUMP PANEL (NEMA 1)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Box, Elec. VSOPD Panel 371-04137-311 1 33
2 Rail, Mounting Contactor 025-29167-000 .09 33
3 O-ring, Neoprene .301ID .064THK 028-12961-021 1 33
4 Switch, High Pressure Cut-out 025-37890-204 1 33
5 Clamp, Din rail 025-29189-000 2 33
6 Heatsink 071-02766-301 1 33
7 Terminal Block 025-39564-000 1 33
8 Terminal Block 025-39800-000 3 33
9 Sealing, Ring 1/2 025-09613-000 1 33
13 Marker, Terminal Block 025-33271-000 3 33
14 Compound, Heat Conductive 013-02997-000 .01 33
15 Locknut, Conduit 025-05701-000 1 33
17 Screw, Tapping #6-32Unc 021-19152-000 2 33
18 Adapter, Bulkhead 023-20859-000 1 33
19 Lockwasher, Th 1/4 021-12507-000 4 33
NEMA 1 VARIABLE PARTS (371-04137-XXX)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
101 Variable Speed Oil Pump Drive (200V-240V, 346V) 024-30468-001
1 33
Variable Speed Oil Pump Drive (380V-480V, 575V/600V) 024-30468-002
102 Bracket, Inductor Mtg. 371-02795-315 1 33
103 Contactor (1M) 024-25522-000 1 33
104 Fuse, Cartridge Type (575V/600V) 025-35903-000
3 33
Fuse, Cartridge Type (346V) 025-35906-000
105 Cover, Xmfr, VS Oil Pump Drive 371-02797-311 1 33
106 Transformer (T2, T3, T4) (575V/600V) 025-33233-000
3 33
Transformer (T2, T3, T4) (346V) 025-33232-000
107 Fuseholder, 3-Pole 025-37863-000 1 33
108
Main Harness (P/H/K Compressors, 200V-240V and 380V-480V) 571-04137-201
1 33 Main Harness (P/H/K Compressors, 575V/600V and 346V) 571-04137-211
Main Harness (Q Compressors, 200V-240V and 380V-480V) 571-04137-221
Main Harness (Q Compressors, 575V/600V and 346V) 571-04137-231
109 Screw, #10-32 021-09567-000 12 33
110 Lockwasher, Hel Spg #10 021-01137-000 12 33
111 Nut, Hex #10-32 021-08670-000 12 33
112 Screw, Tap Thd, Cutting #10-24 021-14727-000 4 33
114 Nut Washer Assy. #10-24 021-18024-000 6 33
115 Inductor (200V-240V) 025-37860-000
1 33
Inductor (380V-480V) 025-37861-000
116 Screw, Machine Pan Hd 1 1/4-20 x 1/2 (200V-240V, 380V-480V) 021-01853-000 8
33
Screw, Machine Pan Hd 1 1/4-20 x 1/2 (575V/600V, 346V) 021-01853-000 4
117 Lockwasher, Th Extnl Int 1/4 021-12507-000 4 33
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 63
Figure 33 - VARIABLE SPEED OIL PUMP CONTROL PANEL (NEMA 1)
LD13054
346V AND 575V/600V UNITS
200V-240V AND 380V-480V UNITS
64 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE SPEED OIL PUMP CONTROL PANEL
NEMA4/12, NEMA4X COMMON PARTS (371-04156-010)
Table 29 - VARIABLE SPEED OIL PUMP PANEL (NEMA 4/12 & NEMA4X)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Box, Elec. VSOPD Panel 371-04156-311 1 34
2 Rail, Mounting Contactor 025-29167-000 .09 34
3 O-ring, Neoprene .301ID .064THK 028-12961-021 1 34
4 Switch, High Pressure Cut-out 025-37890-204 1 34
5 Clamp, Din Rail 025-29189-000 2 34
6 Heatsink 071-02766-301 1 34
7 Terminal Block 025-39564-000 1 34
8 Terminal Block 025-33269-000 3 34
9 Sealing, Ring 1/2 025-09613-000 1 34
13 Marker, Terminal Block 025-33272-000 3 34
14 Compound, Heat Conductive 013-02997-000 .01 34
15 Locknut, Conduit 025-05701-000 1 34
17 Screw, Tapping #6-32Unc 021-19152-000 2 34
19 Sealant, Silicone Rubber 013-02469-000 1 34
20 Lockwasher, Th 1/4 021-12507-000 4 34
NEMA4/12, NEMA4X VARIABLE PARTS (371-04156-XXX)
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
101 Variable Speed Oil Pump Drive (200V-240V) 024-30468-001
1 34
Variable Speed Oil Pump Drive (380V-480V) 024-30468-002
102 Bracket, Inductor Mtg. 371-02795-315 1 34
103 Contactor (1M) (200V-240V, 380V-480V) 024-25522-000 1 34
104 Box, Elec. VSOPD Panel (NEMA 4/12) 371-04156-311
1 34
Box, Elec. VSOPD Panel (NEMA 4X) 371-04156-315
105 Adapter, Bulkhead (NEMA 4/12) 023-20859-000
1 34
Adapter, Bulkhead (NEMA 4X) 025-39306-000
108 Harness, Main (P/H/K Comressors) 571-04137-201
1 34
Harness, Main (Q Compressors) 571-04137-221
114 Nut/Washer Assy. #10-24 021-18024-000 6 34
115 Inductor (200V-240V) 025-37860-000
1 34
Inductor (280V-480V) 025-37861-000
116 Screw, Mach Pan HD Rec'd 1 1/4-20 x 1/2 021-01853-000 8 34
117 Lockwasher Th Extnl Int 1/4 021-12507-000 4 34
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 65
Figure 34 - VARIABLE SPEED OIL PUMP CONTROL PANEL (NEMA 4/12, NEMA4X)
LD13055
66 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
VARIABLE SPEED OIL PUMP CONTROL PANEL
CE COMMON PARTS (371-04936-010)
Table 30 - VARIABLE SPEED OIL PUMP CONTROL PANEL (CE)
ITEM
NUMBER DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Box, Elec. VSOPD Panel 371-04936-311 1 35
2 Rail, Mounting Contactor 025-29167-000 .09 35
3 O-ring, Neoprene .301ID .064THK 028-12961-021 1 35
4 Switch, High Pressure Cut-out 025-37890-204 1 35
5 Clamp, Din Rail 025-29189-000 2 35
6 Heatsink 071-02766-301 1 35
7 Terminal Block 025-39564-000 1 35
9 Sealing, Ring 1/2 025-09613-000 1 35
13 Marker, Terminal Block 025-33272-000 3 35
14 Compound, Heat Conductive 013-02997-000 .01 35
15 Locknut, Conduit 025-05701-000 1 35
17 Screw, Tapping #6-32Unc 021-19152-000 2 35
18 Adapter, Bulkhead 023-20859-000 1 35
19 Sealant, Silicone Rubber 013-02469-000 1 35
20 Lockwasher, Th 1/4 021-12507-000 4 35
21 Switch Disconnect, 30A 600V 024-34015-000 1 35
22 Kit, Door Mounting, Disconnect 024-34016-000 1 35
23 Switch, Disconnect, Accessory, GND Terminal 024-34017-000 1 35
24 Strap, Grounding 525-32508-001 1 35
25 Nut, Keps #8-32 021-17664-000 2 35
CE VARIABLE PARTS (371-04936-010)
ITEM
NUMBER DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
101 Variable Speed Oil Pump Drive (prior 6-2008) 024-30468-002
1 35
Variable Speed Oil Pump Drive (after 6-2008) 024-36133-002
102 Bracket, Inductor Mtg. 371-02795-315 1 35
103 Contactor, (1M) (380V-416V) 024-25522-000 1 35
104 Box, Elec. VSOPD Panel 371-04936-311 1 35
105 Adapter, Bulkhead 025-39306-000 1 35
108 Harness, Main (P/H/K Compressors) 571-0436-201
1 35
Harness, Main (Q Compressors) 571-04936-211
114 Nut/Washer Assy. #10-24 021-21038-001 6 35
115 Inductor 025-37861-000 1 35
116 Screw, Mach. Pan Hd Rec'd 1 1/4-20 x 1/2 021-01853-000 8 35
117 Lockwasher Th Extrnl Int 1/4 021-12507-000 4 35
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 67
Figure 35 - VARIABLE SPEED OIL PUMP CONTROL PANEL (CE)
LD13056
68 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
SYSTEM CONTROL COMPONENTS
Table 31 - SYSTEM CONTROL COMPONENTS
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
3 Sensor, Temperature 3000 Ohms 025-29964-000 5 36
4 Sensor, Condenser Liquid Temperature (P8, P9, H9, and K) 025-29964-000
1 36
Sensor, Condenser Liquid Temperature (Q3-Q7, and P7) 025-39517-000
6 O-ring, Neoprene .644 Id .087 Thk 028-12961-004 2 *
7 Sensor, Temp. Evaporator Refrigerant 025-34159-000
1 * Sensor, Temp. Evaporator Refrigerant (Square Connector) 025-41904-000
21 Diode, Bridge 031-00210-000 1 *
22 Wiring, Resistor 575-00364-001 1 *
48 Gasket, Seal 1" OD x 7/8 028-04836-000 1 36
65 Control, Current CM-2 031-00947-000 1 36
81 Sensor, Flow 025-41573-000 2 36
90 O-ring, Neoprene .644 ID .087 Thk 028-12961-004 1 36
91 Sensor, Temperature 50,000 Ohms DIN 025-39993-000 1 36
93 Well, Thermo 026-32328-000 4 36
108
Sensor, Level R-134a (Q3-Q7/P7/K1-K4) (prior 6-2013) 025-43950-006
1 36
Sensor, Level R-134a (Q3-Q7/P7/K1-K4) (after 6-2013) 025-46044-006
Sensor, Level R-134a (K1-K4/K7) (prior 6-2013) 025-43950-008
Sensor, Level R-134a (K1-K4/K7) (after 6-2013) 025-46044-008
108A Level Control Module (Pushbutton Style) 325-42383-001
108B Level Control Module (Potentiometer Style) 025-34146-000
109 Sensor ("X" and Larger Cond. Shell Codes) 325-40338-000
1 36
109A Module ("X" and Larger Cond. Shell Codes) 325-42383-002
120
Actuator, Electric (2" Valve) 025-38177-000
1
Actuator, Electric (3" and 4" Valve) 025-38178-000 36
Actuator, Electric (5" Valve) 025-38178-000 2
133 Valve, Ball 3/4-16Unf-2A 022-11715-000 1 36
134 Transducer, Pressure R-22/R-134 (VGD Compressor) 025-40088-000 1 36
135 O-ring, Neoprene .414 Id .072 Thk 028-12961-002 1 36
NOTE: Items with an * are NOT represented.
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 69
Figure 36 - WIRING SYSTEM
LD13066
7
70 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
MOTOR MONITORING
Table 32 - MOTOR MONITORING
ITEM DESCRIPTION PART NUMBER QUANTITY/
UNIT FIGURE
1 Motor Monitoring Shielding Cable 025-43432-000 20 FT. *
2 Motor Monitoring CONN CA STR 1/2 025-43523-000 1 37
3 Motor Monitoring Circuit Board 031-02893-004 1 37
4 Motor Leak Detector 025-42937-000 2 38
5 Motor Box Conduit Outlet Box 025-42944-000 2 38
6 Accelerometer 025-42945-000 2 39
7 Accelerometer Cable 025-43349-000 1 39
8 Accelerometer Glue Mount 025-43370-000 1 39
Figure 37 - MOTOR MONITORING ENCLOSURE ASSEMBLY
LD15219
2
3
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 71
4
5
6
7
8
6
7
REF
REF
SEE
DETAIL B
SEE DETAIL B
DETAIL B
REF
REF
MOTOR
SHAFT
Figure 38 - MOTOR MONITORING OPTICAL COOLING COIL LEAK DETECTOR
Figure 39 - MOTOR MONITORING VIBRATION DETECTOR
LD15220
LD15221
72 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
EVAPORATOR TUBES
Table 33 - 3/4" EVAPORATOR TUBES (FLOODED SHELL)
SHELL
CODE
TUBE
QUANTITY
COPPER COPPER NICKEL
SHELL
CODE
Turbo-EPHII Turbo-ESP
STANDARD OPTIONS OPTIONS
0.025 (MT#271) 0.028 (MT#272) 0.035 (MT#273) 0.028 (MT#177) 0.035 (MT#179) 0.025 (MT#321) 0.028 (MT#322) 0.035 (MT#323) 0.025 (MT#371) 0.028 (MT#372) 0.035 (MT#373)
AP 106
007-10004-000 007-10005-000 007-10006-000 007-08410-000 007-08411-000
AP
007-09995-000 007-10197-000 007-10198-000 007-10641-000 007-10642-000 007-10643-000
AQ 130 AQ
AR 159 AR
AS 194 AS
CP 209 CP
CQ 235 CQ
CR 279 CR
CS 336 CS
DP 209
007-10014-000 007-10015-000 007-10016-000 007-08851-000 007-08852-000
DP
007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
DQ 235 DQ
DR 279 DR
DS 336 DS
EP 277
007-10004-000 007-10005-000 007-10006-000 007-08851-000 007-08852-000
EP
007-09995-000 007-10197-000 007-10198-000 007-10641-000 007-10642-000 007-10643-000
EQ 337 EQ
ER 397 ER
ES 468 ES
ET 540 ET
FQ 337
007-10014-000 007-10015-000 007-10016-000 007-08410-000 007-08411-000
FQ
007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
FR 397 FR
FS 468 FS
FT 540 FT
GQ 465
007-10004-000 007-10005-000 007-10006-000 007-08410-000 007-08411-000
GQ
GR 525 GR 007-09995-000 007-10197-000 007-10198-000 007-10641-000 007-10642-000 007-10643-000
GS 594 GS
HQ 465
007-10014-000 007-10015-000 007-10016-000 007-08851-000 007-08852-000
HQ
HR 525 HR 007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
HS 594 HS
JP 498
007-10004-000 007-10005-000 007-10006-000 007-08410-000 007-08411-000
JP
007-09995-000 007-10197-000 007-10198-000 007-10641-000 007-10642-000 007-10643-000
JQ 618 JQ
JR 772 JR
JS 843 JS
KP, KT 498
007-10007-000 007-10008-000 007-10009-000 007-08849-000 007-08850-000
KP, KT
007-10199-000 007-10200-000 007-10201-000 007-10647-000 007-10648-000 007-10649-000
KQ, KV 618 KQ, KV
KR, KW 772 KR, KW
KS, KX 843 KS, KX
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 73
Table 33 - 3/4" EVAPORATOR TUBES (FLOODED SHELL)
SHELL
CODE
TUBE
QUANTITY
COPPER COPPER NICKEL
SHELL
CODE
Turbo-EPHII Turbo-ESP
STANDARD OPTIONS OPTIONS
0.025 (MT#271) 0.028 (MT#272) 0.035 (MT#273) 0.028 (MT#177) 0.035 (MT#179) 0.025 (MT#321) 0.028 (MT#322) 0.035 (MT#323) 0.025 (MT#371) 0.028 (MT#372) 0.035 (MT#373)
AP 106
007-10004-000 007-10005-000 007-10006-000 007-08410-000 007-08411-000
AP
007-09995-000 007-10197-000 007-10198-000 007-10641-000 007-10642-000 007-10643-000
AQ 130 AQ
AR 159 AR
AS 194 AS
CP 209 CP
CQ 235 CQ
CR 279 CR
CS 336 CS
DP 209
007-10014-000 007-10015-000 007-10016-000 007-08851-000 007-08852-000
DP
007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
DQ 235 DQ
DR 279 DR
DS 336 DS
EP 277
007-10004-000 007-10005-000 007-10006-000 007-08851-000 007-08852-000
EP
007-09995-000 007-10197-000 007-10198-000 007-10641-000 007-10642-000 007-10643-000
EQ 337 EQ
ER 397 ER
ES 468 ES
ET 540 ET
FQ 337
007-10014-000 007-10015-000 007-10016-000 007-08410-000 007-08411-000
FQ
007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
FR 397 FR
FS 468 FS
FT 540 FT
GQ 465
007-10004-000 007-10005-000 007-10006-000 007-08410-000 007-08411-000
GQ
GR 525 GR 007-09995-000 007-10197-000 007-10198-000 007-10641-000 007-10642-000 007-10643-000
GS 594 GS
HQ 465
007-10014-000 007-10015-000 007-10016-000 007-08851-000 007-08852-000
HQ
HR 525 HR 007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
HS 594 HS
JP 498
007-10004-000 007-10005-000 007-10006-000 007-08410-000 007-08411-000
JP
007-09995-000 007-10197-000 007-10198-000 007-10641-000 007-10642-000 007-10643-000
JQ 618 JQ
JR 772 JR
JS 843 JS
KP, KT 498
007-10007-000 007-10008-000 007-10009-000 007-08849-000 007-08850-000
KP, KT
007-10199-000 007-10200-000 007-10201-000 007-10647-000 007-10648-000 007-10649-000
KQ, KV 618 KQ, KV
KR, KW 772 KR, KW
KS, KX 843 KS, KX
EVAPORATOR TUBES (CONT'D)
TABLE 33 (CONT'D) - 3/4" EVAPORATOR TUBES (FLOODED SHELL)
74 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
EVAPORATOR TUBES (CONT'D)
TABLE 33 (CONT'D) - 3/4" EVAPORATOR TUBES (FLOODED SHELL)
SHELL
CODE
TUBE
QUANTITY
COPPER COPPER NICKEL
SHELL
CODE
Turbo-EPHII Turbo-ESP
STANDARD OPTIONS OPTIONS
0.025 (MT#271) 0.028 (MT#272) 0.035 (MT#273) 0.028 (MT#177) 0.035 (MT#179) 0.025 (MT#321) 0.028 (MT#322) 0.035 (MT#323) 0.025 (MT#371) 0.028 (MT#372) 0.035 (MT#373)
LQ 618
007-10014-000 007-10015-000 007-10006-000 007-08851-000 007-08852-000
LQ
LR 772 LR 007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
LS 843 LS
MQ 782
007-10007-000 007-10008-000 007-10009-000 007-08849-000 007-08850-000
MQ
MR 912 MR 007-10199-000 007-10200-000 007-10201-000 007-10647-000 007-10648-000 007-10649-000
MS 1046 MS
NQ 782
007-10014-000 007-10015-000 007-10016-000 007-08851-000 007-08852-000
NQ
NR 912 NR 007-10206-000 007-10207-000 007-10198-000 007-10644-000 007-10645-000 007-10646-000
NS 1046 NS
PQ 888
007-10007-000 007-10008-000 007-10009-00 007-08849-000 007-08850-000
PQ
PR 1009 PR 007-10199-000 007-10200-000 007-10201-000 007-10647-000 007-10648-000 007-10649-000
PS 1083 PS
QQ 888
007-10014-000 007-10015-000 007-10016-000 007-08851-000 007-08852-000
007-10206-000 007-10207-000 007-10198-000 007-10644-000 007-10645-000 007-10646-000
QR 1009 QR
QS 1083 QS
QT 1161 QT
QV 1335 QV
RP 1000
007-10014-000 007-10015-000 007-10016-000 007-08851-000 007-08852-000
RP
007-10206-000 007-10207-000 007-10198-000 007-10644-000 007-10645-000 007-10646-000
RQ 1215 RQ
RR 1234 RR
RS 1484 RS
RT 1493 RT
RV 1742 RV
SQ 1215
007-10017-000 007-10018-000 007-10019-000 007-09622-000 007-09623-000
SQ
SS 1484 SS 007-10209-000 007-10210-000 007-10211-000 007-10650-000 007-10651-000 007-10652-000
SV 1742 SV
WP 1000
007-10048-000 007-10049-000 007-10050-000 007-10038-000 007-10039-000
WP
WR 1234 WR 007-10212-000 007-10213-000 007-10214-000 007-10653-000 007-10654-000 007-10655-000
WT 1493 WT
XQ 1537
007-10014-000 007-10015-000 007-10016-000 007-08851-000 007-08852-000
XQ
XR 1699 XR 007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
XS 1850 XS
ZQ 1537
007-10017-000 007-10018-000 007-10019-000 007-09622-000 007-09623-000
ZQ
ZR 1699 ZR 007-10209-000 007-10210-000 007-10211-000 007-10650-000 007-10651-000 007-10652-000
ZS 1850 ZS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 75
EVAPORATOR TUBES (CONT'D)
SHELL
CODE
TUBE
QUANTITY
COPPER COPPER NICKEL
SHELL
CODE
Turbo-EPHII Turbo-ESP
STANDARD OPTIONS OPTIONS
0.025 (MT#271) 0.028 (MT#272) 0.035 (MT#273) 0.028 (MT#177) 0.035 (MT#179) 0.025 (MT#321) 0.028 (MT#322) 0.035 (MT#323) 0.025 (MT#371) 0.028 (MT#372) 0.035 (MT#373)
LQ 618
007-10014-000 007-10015-000 007-10006-000 007-08851-000 007-08852-000
LQ
LR 772 LR 007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
LS 843 LS
MQ 782
007-10007-000 007-10008-000 007-10009-000 007-08849-000 007-08850-000
MQ
MR 912 MR 007-10199-000 007-10200-000 007-10201-000 007-10647-000 007-10648-000 007-10649-000
MS 1046 MS
NQ 782
007-10014-000 007-10015-000 007-10016-000 007-08851-000 007-08852-000
NQ
NR 912 NR 007-10206-000 007-10207-000 007-10198-000 007-10644-000 007-10645-000 007-10646-000
NS 1046 NS
PQ 888
007-10007-000 007-10008-000 007-10009-00 007-08849-000 007-08850-000
PQ
PR 1009 PR 007-10199-000 007-10200-000 007-10201-000 007-10647-000 007-10648-000 007-10649-000
PS 1083 PS
QQ 888
007-10014-000 007-10015-000 007-10016-000 007-08851-000 007-08852-000
007-10206-000 007-10207-000 007-10198-000 007-10644-000 007-10645-000 007-10646-000
QR 1009 QR
QS 1083 QS
QT 1161 QT
QV 1335 QV
RP 1000
007-10014-000 007-10015-000 007-10016-000 007-08851-000 007-08852-000
RP
007-10206-000 007-10207-000 007-10198-000 007-10644-000 007-10645-000 007-10646-000
RQ 1215 RQ
RR 1234 RR
RS 1484 RS
RT 1493 RT
RV 1742 RV
SQ 1215
007-10017-000 007-10018-000 007-10019-000 007-09622-000 007-09623-000
SQ
SS 1484 SS 007-10209-000 007-10210-000 007-10211-000 007-10650-000 007-10651-000 007-10652-000
SV 1742 SV
WP 1000
007-10048-000 007-10049-000 007-10050-000 007-10038-000 007-10039-000
WP
WR 1234 WR 007-10212-000 007-10213-000 007-10214-000 007-10653-000 007-10654-000 007-10655-000
WT 1493 WT
XQ 1537
007-10014-000 007-10015-000 007-10016-000 007-08851-000 007-08852-000
XQ
XR 1699 XR 007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
XS 1850 XS
ZQ 1537
007-10017-000 007-10018-000 007-10019-000 007-09622-000 007-09623-000
ZQ
ZR 1699 ZR 007-10209-000 007-10210-000 007-10211-000 007-10650-000 007-10651-000 007-10652-000
ZS 1850 ZS
TABLE 33 (CONT'D) - 3/4" EVAPORATOR TUBES (FLOODED SHELL)
76 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
EVAPORATOR TUBES (CONT'D)
Table 34 - 1" EVAPORATOR TUBES (FLOODED SHELL)
SHELL
CODE
TUBE
QUANTITY
COPPER COPPER NICKEL
SHELL
CODE
Turbo-ESP
STANDARD OPTIONS OPTIONS
0.025 (MT#286) 0.028 (MT#287) 0.035 (MT#288) 0.025 (MT#326) 0.028 (MT#327) 0.035 (MT#328) 0.025 (MT#376) 0.028 (MT#377) 0.035 (MT#378)
K2,K5 312
007-10086-000 007-10087-000 007-10088-000 007-10215-000 007-10216-000 007-10217-000
K2,K5
K3,K6 366 K3,K6 007-10656-000 007-10657-000 007-10658-000
K4,K7 421 K4,K7
M2 339
007-10215-000 007-10216-000 007-10217-000 007-10101-000 007-10102-000 007-10103-000
M2
M3 402 M3 007-10656-000 007-10657-000 007-10658-000
M4 499 M4
N2 339
007-10134-000 007-10222-000 007-10223-000 007-10108-000 007-10109-000 007-10110-000
N2
N3 402 N3 007-10659-000 007-10660-000 007-10661-000
N4 499 N4
P2 427
007-10215-000 007-10216-000 007-10217-000 007-10101-000 007-10102-000 007-10103-000
P2
P3 501 P3 007-10656-000 007-10657-000 007-10658-000
P4 568 P4
Q2 427
007-10134-000 007-10222-000 007-10223-000 007-10108-000 007-10109-000 007-10110-000
Q2
Q3 501 Q3 007-10659-000 007-10660-000 007-10661-000
Q4 568 Q4
R2 643
007-10134-000 007-10222-000 007-10223-000 007-10108-000 007-10109-000 007-10110-000
R2
007-10656-000 007-10660-000 007-10661-000
R3 655 R3
R4 727 R4
R5 779 R5
R6 815 R6
R7 887 R7
S3 655
007-10224-000 007-10225-000 007-10226-000 007-10111-000 007-10112-000 007-10113-000
S3
S5 779 S5 007-10659-000 007-10663-000 007-10664-000
S7 887 S7
W1 537
007-10227-000 007-10228-000 007-10229-000 007-10117-000 007-10118-000 007-10119-000
W1
007-10665-000 007-10666-000 007-10667-000
W2 643 W2
W4 727 W4
W6 815 W6
X2 807
007-10134-000 007-10222-000 007-10223-000 007-10108-000 007-10109-000 007-10110-000
X2
X3 954 X3 007-10659-000 007-10660-000 007-10661-000
X4 1063 X4
Z1 670
007-10224-000 007-10225-000 007-10226-000 007-10111-000 007-10112-000 007-10113
Z1
007-10662-000 007-10663-000 007-10664-000
Z2 807 Z2
Z3 954 Z3
Z4 1063 Z4
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 77
Table 34 - 1" EVAPORATOR TUBES (FLOODED SHELL)
SHELL
CODE
TUBE
QUANTITY
COPPER COPPER NICKEL
SHELL
CODE
Turbo-ESP
STANDARD OPTIONS OPTIONS
0.025 (MT#286) 0.028 (MT#287) 0.035 (MT#288) 0.025 (MT#326) 0.028 (MT#327) 0.035 (MT#328) 0.025 (MT#376) 0.028 (MT#377) 0.035 (MT#378)
K2,K5 312
007-10086-000 007-10087-000 007-10088-000 007-10215-000 007-10216-000 007-10217-000
K2,K5
K3,K6 366 K3,K6 007-10656-000 007-10657-000 007-10658-000
K4,K7 421 K4,K7
M2 339
007-10215-000 007-10216-000 007-10217-000 007-10101-000 007-10102-000 007-10103-000
M2
M3 402 M3 007-10656-000 007-10657-000 007-10658-000
M4 499 M4
N2 339
007-10134-000 007-10222-000 007-10223-000 007-10108-000 007-10109-000 007-10110-000
N2
N3 402 N3 007-10659-000 007-10660-000 007-10661-000
N4 499 N4
P2 427
007-10215-000 007-10216-000 007-10217-000 007-10101-000 007-10102-000 007-10103-000
P2
P3 501 P3 007-10656-000 007-10657-000 007-10658-000
P4 568 P4
Q2 427
007-10134-000 007-10222-000 007-10223-000 007-10108-000 007-10109-000 007-10110-000
Q2
Q3 501 Q3 007-10659-000 007-10660-000 007-10661-000
Q4 568 Q4
R2 643
007-10134-000 007-10222-000 007-10223-000 007-10108-000 007-10109-000 007-10110-000
R2
007-10656-000 007-10660-000 007-10661-000
R3 655 R3
R4 727 R4
R5 779 R5
R6 815 R6
R7 887 R7
S3 655
007-10224-000 007-10225-000 007-10226-000 007-10111-000 007-10112-000 007-10113-000
S3
S5 779 S5 007-10659-000 007-10663-000 007-10664-000
S7 887 S7
W1 537
007-10227-000 007-10228-000 007-10229-000 007-10117-000 007-10118-000 007-10119-000
W1
007-10665-000 007-10666-000 007-10667-000
W2 643 W2
W4 727 W4
W6 815 W6
X2 807
007-10134-000 007-10222-000 007-10223-000 007-10108-000 007-10109-000 007-10110-000
X2
X3 954 X3 007-10659-000 007-10660-000 007-10661-000
X4 1063 X4
Z1 670
007-10224-000 007-10225-000 007-10226-000 007-10111-000 007-10112-000 007-10113
Z1
007-10662-000 007-10663-000 007-10664-000
Z2 807 Z2
Z3 954 Z3
Z4 1063 Z4
EVAPORATOR TUBES (CONT'D)
TABLE 34 (CONT'D) - 1" EVAPORATOR TUBES (FLOODED SHELL)
78 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 35 - 3/4" EVAPORATOR TUBES (HYBRID FALLING FILM-FLOODED SHELL)
SHELL
CODE
TUBE
QUANTITY
COPPER COPPER NICKEL
SHELL
CODE
Turbo-EHPII Turbo-ESP
STANDARD OPTIONS OPTIONS
0.025 (MT#271) 0.028 (MT#272) 0.035 (MT#273) 0.028 (MT#177) 0.035 (MT#179) 0.025 (MT#321) 0.028 (MT#322) 0.035 (MT#323) 0.025 (MT#371) 0.028 (MT#372) 0.035 (MT#373)
AC 223
007-09995-000 007-10197-000 007-10198-000 007-08410-000 007-08411-000
AC
007-09995-000 007-10197-000 0007-10198-000 007-10641-000 007-10642-000 007-10643-000
AD 279 AD
CC 252 CC
CD 316 CD
CE 402 CE
DC 252
007-10206-000 007-10207-000 007-10208-000 007-08851-000 007-08852-000
DC
DD 316 DD 007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
DE 402 DE
EC 310
007-09995-000 007-10197-000 007-10198-000 007-08410-000 007-08411-000
EC
ED 410 ED 007-09995-000 007-10197-000 007-10198-000 007-10641-000 007-10642-000 007-10643-000
EE 518 EE
FC 310
007-10206-000 007-10207-000 007-10208-000 007-08851-000 007-08852-000
FC
FD 410 FD 007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
FE 518 FE
GC 409
007-09995-000 007-10197-000 007-10198-000 007-08410-000 007-08411-000
GC
GD 512 GD 007-10699-000 00-10700-000 007-10701-000 007-10711-000 007-10712-000 007-10713-000
GE 667 GE
HC 409
007-10206-000 007-10207-000 007-10208-000 007-08851-000 007-08852-000
HC
HD 512 HD 007-10702-000 007-10703-000 007-10704-000 007-10714-000 007-10715-000 007-10716-000
HE 667 HE
KC 670
007-10199-000 007-10200-000 007-10201-000 007-08849-000 007-08850-000
KC
007-10203-000 007-10204-000 007-10205-000 007-10692-000 007-10693-000 007-10694-000
KD 881 KD
IB 670
007-10011-000 007-10012-000 007-10013-000 007-08830-000 007-08644-000
IB
007-10203-000 007-10204-000 007-10205-000 007-10692-000 007-10693-000 007-10694-000
ID 740 ID
IF 822 IF
IH 920 IH
MB 782
007-10011-000 007-10012-000 007-10013-000 007-08830-000 007-08644-000
MB
MD 912 MD 007-10203-000 007-10204-000 007-10205-000 007-10692-000 007-10693-000 007-10694-000
MF 1063 MF
NB 782
007-10760-000 007-10761-000 007-10762-000 007-10758-000 007-10759-000
NB
ND 912 ND 007-10749-000 007-10750-000 007-10751-000 007-10743-000 007-10744-000 007-10745-000
NF 1063 NF
PB 888
007-10011-000 007-10012-000 007-10013-000 007-08830-000 007-08644-000
PB
PD 1009 PD 007-10203-000 007-10204-000 007-10205-000 007-10692-000 007-10693-000 007-10694-000
PF 1161 PF
QB 888
007-10760-000 007-10761-000 007-10762-000 007-10758-000 007-10759-000
QB
007-10749-000 007-10750-000 007-10751-000 007-10743-000 007-10744-000 007-10745-000
QD 1009 QD
QF 1161 QF
QH 1371 QH
EVAPORATOR TUBES (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 79
Table 35 - 3/4" EVAPORATOR TUBES (HYBRID FALLING FILM-FLOODED SHELL)
SHELL
CODE
TUBE
QUANTITY
COPPER COPPER NICKEL
SHELL
CODE
Turbo-EHPII Turbo-ESP
STANDARD OPTIONS OPTIONS
0.025 (MT#271) 0.028 (MT#272) 0.035 (MT#273) 0.028 (MT#177) 0.035 (MT#179) 0.025 (MT#321) 0.028 (MT#322) 0.035 (MT#323) 0.025 (MT#371) 0.028 (MT#372) 0.035 (MT#373)
AC 223
007-09995-000 007-10197-000 007-10198-000 007-08410-000 007-08411-000
AC
007-09995-000 007-10197-000 0007-10198-000 007-10641-000 007-10642-000 007-10643-000
AD 279 AD
CC 252 CC
CD 316 CD
CE 402 CE
DC 252
007-10206-000 007-10207-000 007-10208-000 007-08851-000 007-08852-000
DC
DD 316 DD 007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
DE 402 DE
EC 310
007-09995-000 007-10197-000 007-10198-000 007-08410-000 007-08411-000
EC
ED 410 ED 007-09995-000 007-10197-000 007-10198-000 007-10641-000 007-10642-000 007-10643-000
EE 518 EE
FC 310
007-10206-000 007-10207-000 007-10208-000 007-08851-000 007-08852-000
FC
FD 410 FD 007-10206-000 007-10207-000 007-10208-000 007-10644-000 007-10645-000 007-10646-000
FE 518 FE
GC 409
007-09995-000 007-10197-000 007-10198-000 007-08410-000 007-08411-000
GC
GD 512 GD 007-10699-000 00-10700-000 007-10701-000 007-10711-000 007-10712-000 007-10713-000
GE 667 GE
HC 409
007-10206-000 007-10207-000 007-10208-000 007-08851-000 007-08852-000
HC
HD 512 HD 007-10702-000 007-10703-000 007-10704-000 007-10714-000 007-10715-000 007-10716-000
HE 667 HE
KC 670
007-10199-000 007-10200-000 007-10201-000 007-08849-000 007-08850-000
KC
007-10203-000 007-10204-000 007-10205-000 007-10692-000 007-10693-000 007-10694-000
KD 881 KD
IB 670
007-10011-000 007-10012-000 007-10013-000 007-08830-000 007-08644-000
IB
007-10203-000 007-10204-000 007-10205-000 007-10692-000 007-10693-000 007-10694-000
ID 740 ID
IF 822 IF
IH 920 IH
MB 782
007-10011-000 007-10012-000 007-10013-000 007-08830-000 007-08644-000
MB
MD 912 MD 007-10203-000 007-10204-000 007-10205-000 007-10692-000 007-10693-000 007-10694-000
MF 1063 MF
NB 782
007-10760-000 007-10761-000 007-10762-000 007-10758-000 007-10759-000
NB
ND 912 ND 007-10749-000 007-10750-000 007-10751-000 007-10743-000 007-10744-000 007-10745-000
NF 1063 NF
PB 888
007-10011-000 007-10012-000 007-10013-000 007-08830-000 007-08644-000
PB
PD 1009 PD 007-10203-000 007-10204-000 007-10205-000 007-10692-000 007-10693-000 007-10694-000
PF 1161 PF
QB 888
007-10760-000 007-10761-000 007-10762-000 007-10758-000 007-10759-000
QB
007-10749-000 007-10750-000 007-10751-000 007-10743-000 007-10744-000 007-10745-000
QD 1009 QD
QF 1161 QF
QH 1371 QH
EVAPORATOR TUBES (CONT'D)
TABLE 35 (CONT'D) - 3/4" EVAPORATOR TUBES (HYBRID FALLING FILM-FLOODED SHELL)
80 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 36 - 1" EVAPORATOR TUBES (HYBRID FALLING FILM-FLOODED SHELL)
SHELL
CODE
TUBE
QUANTITY
COPPER COPPER NICKEL
SHELL
CODE
COPPER NICKEL
STANDARD OPTIONS OPTIONS
0.025 (MT#286) 0.028 (MT#287) 0.035 (MT#288) 0.025 (MT#326) 0.028 (MT#327) 0.035 (MT#328) 0.025 (MT#376) 0.028 (MT#377) 0.035 (MT#378)
A3 112
007-10430-000 007-10431-000 007-10432-000 007-10430-000
A3
007-10431-000 007-10432-000 007-10668-000 007-10669-000 007-10670-000
A4 135 A4
C3 124 C3
C4 156 C4
C5 203 C5
D3 124
007-10134-000 007-10222-000 007-10223-000 007-10134-000
D3
D4 156 D4 007-10222-000 007-10223-000 007-10659-000 007-10660-000 007-10661-000
D5 203 D5
E3 164
007-10430-000 007-10431-000 007-10432-000 007-10430-000
E3
E4 205 E4 007-10431-000 007-10432-000 007-10668-000 007-10669-000 007-10670-000
E5 253 E5
F3 164
007-10134-000 007-10222-000 007-10223-000 007-10134-000
F3
F4 205 F4 007-10222-000 007-10223-000 007-10659-000 007-10660-000 007-10661-000
F5 253 F5
G3 211
007-10430-000 007-10431-000 007-10432-000 00710705-000
G3
G4 264 G4 007-10706-000 007-10707-000 007-10717-000 007-10718-000 007-10719-000
G5 328 G5
H3 211
007-10134-000 007-10222-000 007-10223-000 007-10708-000
H3
H4 264 H4 007-10709-000 007-10710-000 007-10720-000 007-10721-000 007-10722-000
H5 328 H5
K8 256
007-10215-000 007-10216-000 007-10217-000 007-10219-000
K8
K9 342 K9 007-10220-000 007-10221-000 007-10695-000 007-10696-000 007-10697-000
K0 448 K0
I2 256
007-10090-000 007-10091-000 007-10092-000 007-10219-000
I2
007-10220-000 007-10221-000 007-10695-000 007-10696-000 007-10697-000
I4 321 I4
I6 386 I6
I8 474 I8
M5 339
007-10090-000 007-10091-000 007-10092-000 007-10219-000
M5
007-10220-000 007-10221-000 007-10695-000 007-10696-000 007-10697-000
M7 402 M7
M8 499 M8
M9 566 M9
N5 339
007-10763-000 007-10764-000 007-10065-000 007-10752-000
N5
007-10753-000 007-10754-000 007-10746-000 007-10747-000 007-10748-000
N7 402 N7
N8 499 N8
N9 566 N9
P5 427
007-10090-000 007-10091-000 007-10092-000 007-10219-000
P5
P7 501 P7 007-10220-000 007-10221-000 007-10695-000 007-10696-000 007-10697-000
P8 600 P8
Q5 427
007-10763-000 007-10764-000 007-10765-000 007-10752-000
Q5
007-10753-000 007-10754-000 007-10746-000 007-10747-000 007-10748-000
Q7 501 Q7
Q8 600 Q8
Q9 719 Q9
EVAPORATOR TUBES (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 81
Table 36 - 1" EVAPORATOR TUBES (HYBRID FALLING FILM-FLOODED SHELL)
SHELL
CODE
TUBE
QUANTITY
COPPER COPPER NICKEL
SHELL
CODE
COPPER NICKEL
STANDARD OPTIONS OPTIONS
0.025 (MT#286) 0.028 (MT#287) 0.035 (MT#288) 0.025 (MT#326) 0.028 (MT#327) 0.035 (MT#328) 0.025 (MT#376) 0.028 (MT#377) 0.035 (MT#378)
A3 112
007-10430-000 007-10431-000 007-10432-000 007-10430-000
A3
007-10431-000 007-10432-000 007-10668-000 007-10669-000 007-10670-000
A4 135 A4
C3 124 C3
C4 156 C4
C5 203 C5
D3 124
007-10134-000 007-10222-000 007-10223-000 007-10134-000
D3
D4 156 D4 007-10222-000 007-10223-000 007-10659-000 007-10660-000 007-10661-000
D5 203 D5
E3 164
007-10430-000 007-10431-000 007-10432-000 007-10430-000
E3
E4 205 E4 007-10431-000 007-10432-000 007-10668-000 007-10669-000 007-10670-000
E5 253 E5
F3 164
007-10134-000 007-10222-000 007-10223-000 007-10134-000
F3
F4 205 F4 007-10222-000 007-10223-000 007-10659-000 007-10660-000 007-10661-000
F5 253 F5
G3 211
007-10430-000 007-10431-000 007-10432-000 00710705-000
G3
G4 264 G4 007-10706-000 007-10707-000 007-10717-000 007-10718-000 007-10719-000
G5 328 G5
H3 211
007-10134-000 007-10222-000 007-10223-000 007-10708-000
H3
H4 264 H4 007-10709-000 007-10710-000 007-10720-000 007-10721-000 007-10722-000
H5 328 H5
K8 256
007-10215-000 007-10216-000 007-10217-000 007-10219-000
K8
K9 342 K9 007-10220-000 007-10221-000 007-10695-000 007-10696-000 007-10697-000
K0 448 K0
I2 256
007-10090-000 007-10091-000 007-10092-000 007-10219-000
I2
007-10220-000 007-10221-000 007-10695-000 007-10696-000 007-10697-000
I4 321 I4
I6 386 I6
I8 474 I8
M5 339
007-10090-000 007-10091-000 007-10092-000 007-10219-000
M5
007-10220-000 007-10221-000 007-10695-000 007-10696-000 007-10697-000
M7 402 M7
M8 499 M8
M9 566 M9
N5 339
007-10763-000 007-10764-000 007-10065-000 007-10752-000
N5
007-10753-000 007-10754-000 007-10746-000 007-10747-000 007-10748-000
N7 402 N7
N8 499 N8
N9 566 N9
P5 427
007-10090-000 007-10091-000 007-10092-000 007-10219-000
P5
P7 501 P7 007-10220-000 007-10221-000 007-10695-000 007-10696-000 007-10697-000
P8 600 P8
Q5 427
007-10763-000 007-10764-000 007-10765-000 007-10752-000
Q5
007-10753-000 007-10754-000 007-10746-000 007-10747-000 007-10748-000
Q7 501 Q7
Q8 600 Q8
Q9 719 Q9
EVAPORATOR TUBES (CONT'D)
TABLE 36 (CONT'D) - 1" EVAPORATOR TUBES (HYBRID FALLING FILM-FLOODED SHELL)
82 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 37 - 3/4" CONDENSER TUBES
SHELL
CODE
TUBE
QUANTITY
CONDENSER/
SUB-COOLER
COPPER
SHELL
CODE
COPPER NICKEL COPPER (SMOOTH BORE)
STANDARD OPTIONS OPTIONS
0.025 (MT260#) 0.028 (MT#261) 0.035 (MT#262) 0.028 (MT#201) 0.035 (MT#203) 0.028 (MT#225) 0.035 (MT#226)
AP 136/16
007-09289-000 007-09282-000 007-09283-000
AP
007-08412-000 007-07935-000 007-09200-000 007-08518-000
AQ 178/16 AQ
AR 200/16 AR
AS 228/16 AS
CP 223/24
007-09289-000 007-09282-000 007-09823-000
CP
007-08412-000 007-07935-000 007-09200-000 007-08518-000
CQ 260/24 CQ
CR 331/24 CR
CS 419/24 CS
DP 223/24
007-09265-000 007-09266-000 007-09627-000
DP
007-09857-000 007-09858-000 007-08857-000 007-08858-000
DQ 260/24 DQ
DR 331/24 DR
DS 419/24 DS
EP 323/32
007-09289-000 007-09282-000 007-09283-000
EP
007-08412-000 007-07935-000 007-09200-000 007-08518-000
EQ 394/32 EQ
ER 470/32 ER
ES 523/32 ES
ET 585/32 ET
EV 460/42 EV
EW 513/42 EW
EX 575/42 EX
FQ 394/32
007-09265-000 007-09266-000 007-09267-000
FQ
007-09857-000 007-09858-000 007-08857-000 007-08858-000
FR 470/32 FR
FS 523/32 FS
FT 585/32 FT
FV 460/42 FV
FW 513/42 FW
FX 575/42 FX
JP 451/51
007-09289-000 007-09282-000 007-09283-000
JP
007-08412-000 007-07935-000 007-09200-000 007-08518-000
JQ 549/51 JQ
JR 735/51 JR
JS 823/51 JS
KP 451/51
007-09262-000 007-09263-000 007-09264-000
KP
007-09859-000 007-09860-000 007-08650-000 007-08641-000
KQ 549/51 KQ
KR 735/51 KR
KS 823/51 KS
CONDENSER TUBES
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 83
Table 37 - 3/4" CONDENSER TUBES
SHELL
CODE
TUBE
QUANTITY
CONDENSER/
SUB-COOLER
COPPER
SHELL
CODE
COPPER NICKEL COPPER (SMOOTH BORE)
STANDARD OPTIONS OPTIONS
0.025 (MT260#) 0.028 (MT#261) 0.035 (MT#262) 0.028 (MT#201) 0.035 (MT#203) 0.028 (MT#225) 0.035 (MT#226)
AP 136/16
007-09289-000 007-09282-000 007-09283-000
AP
007-08412-000 007-07935-000 007-09200-000 007-08518-000
AQ 178/16 AQ
AR 200/16 AR
AS 228/16 AS
CP 223/24
007-09289-000 007-09282-000 007-09823-000
CP
007-08412-000 007-07935-000 007-09200-000 007-08518-000
CQ 260/24 CQ
CR 331/24 CR
CS 419/24 CS
DP 223/24
007-09265-000 007-09266-000 007-09627-000
DP
007-09857-000 007-09858-000 007-08857-000 007-08858-000
DQ 260/24 DQ
DR 331/24 DR
DS 419/24 DS
EP 323/32
007-09289-000 007-09282-000 007-09283-000
EP
007-08412-000 007-07935-000 007-09200-000 007-08518-000
EQ 394/32 EQ
ER 470/32 ER
ES 523/32 ES
ET 585/32 ET
EV 460/42 EV
EW 513/42 EW
EX 575/42 EX
FQ 394/32
007-09265-000 007-09266-000 007-09267-000
FQ
007-09857-000 007-09858-000 007-08857-000 007-08858-000
FR 470/32 FR
FS 523/32 FS
FT 585/32 FT
FV 460/42 FV
FW 513/42 FW
FX 575/42 FX
JP 451/51
007-09289-000 007-09282-000 007-09283-000
JP
007-08412-000 007-07935-000 007-09200-000 007-08518-000
JQ 549/51 JQ
JR 735/51 JR
JS 823/51 JS
KP 451/51
007-09262-000 007-09263-000 007-09264-000
KP
007-09859-000 007-09860-000 007-08650-000 007-08641-000
KQ 549/51 KQ
KR 735/51 KR
KS 823/51 KS
CONDENSER TUBES (CONT'D)
TABLE 37 (CONT'D) - 3/4" CONDENSER TUBES
84 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
SHELL
CODE
TUBE
QUANTITY
CONDENSER/
SUB-COOLER
COPPER
SHELL
CODE
COPPER NICKEL COPPER (SMOOTH BORE)
STANDARD OPTIONS OPTIONS
0.025 (MT260#) 0.028 (MT#261) 0.035 (MT#262) 0.028 (MT#201) 0.035 (MT#203) 0.028 (MT#225) 0.035 (MT#226)
LQ 549/51
007-09265-000 007-09266-000 007-09267-000
LQ
LR 735/51 LR 007-09857-000 007-09858-000 007-08857-000 007-08858-000
LS 823/51 LS
MP (H9) 611/84
007-09262-000 007-09263-000 007-09264-000
MP (H9)
007-09859-000 007-09860-000 007-08650-000 007-08641-000
MQ (H9) 731/84 MQ (H9)
MR (H9) 851/84 MR (H9)
MS (H9) 953/84 MS (H9)
MP (K1/K2) 611/84
007-09262-000 007-09263-000 007-09264-000
MP (K1/K2)
007-09859-000 007-09860-000 007-08650-000 007-08641-000
MQ (K1/K2) 731/84 MQ (K1/K2)
MR (K1/K2) 851/84 MR (K1/K2)
MS (K1/K2) 953/84 MS (K1/K2)
NP 611/84
007-09265-000 007-09266-000 007-09267
NP
007-09857-000 007-09858-000 007-08857-000 007-08858-000
NQ 731/84 NQ
NR 851/84 NR
NS 953/84 NS
PQ 1061/100
007-09262-000 007-09263-000 007-09264-000
PQ
PR 1199/100 PR 007-09859-000 007-09860-000 007-08650-000 007-08641-000
PS 1341/100 PS
QQ 1061/100
007-09265-000 007-09266-000 007-09267-000
QR 1199/100 QR 007-09857-000 007-09858-000 007-08857-000 007-08858-000
QS 1341/100 QS
RQ 1436/120
007-09265-000 007-09266-000 007-09267-000
RQ
RR 1589/120 RR 007-09857-000 007-09858-000 007-08857-000 007-08858-000
RS 1704/120 RS
SQ 1436/120
007-09608-000 007-09626-000 007-09627-000
SQ
SR 1589/120 SR 007-09861-000 007-09862-000 007-09633-000 007-09634-000
SS 1704/120 SS
TP 1567/144
007-09265-000 007-09266-000 007-09267-000
TP
007-09861-000 007-09862-000 007-09633-000 007-09634-000
TQ 1750/144 TQ
TR 1941/144 TR
TS 2053/144 TS
VP 1567/144
007-09608-000 007-09626-000 007-09627-000
VP
007-09861-000 007-09862-000 007-09633-00 007-09634-000
VQ 1750/144 VQ
VR 1941/144 VR
VS 2053/144 VS
CONDENSER TUBES (CONT'D)
TABLE 37 (CONT'D) - 3/4" CONDENSER TUBES
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 85
SHELL
CODE
TUBE
QUANTITY
CONDENSER/
SUB-COOLER
COPPER
SHELL
CODE
COPPER NICKEL COPPER (SMOOTH BORE)
STANDARD OPTIONS OPTIONS
0.025 (MT260#) 0.028 (MT#261) 0.035 (MT#262) 0.028 (MT#201) 0.035 (MT#203) 0.028 (MT#225) 0.035 (MT#226)
LQ 549/51
007-09265-000 007-09266-000 007-09267-000
LQ
LR 735/51 LR 007-09857-000 007-09858-000 007-08857-000 007-08858-000
LS 823/51 LS
MP (H9) 611/84
007-09262-000 007-09263-000 007-09264-000
MP (H9)
007-09859-000 007-09860-000 007-08650-000 007-08641-000
MQ (H9) 731/84 MQ (H9)
MR (H9) 851/84 MR (H9)
MS (H9) 953/84 MS (H9)
MP (K1/K2) 611/84
007-09262-000 007-09263-000 007-09264-000
MP (K1/K2)
007-09859-000 007-09860-000 007-08650-000 007-08641-000
MQ (K1/K2) 731/84 MQ (K1/K2)
MR (K1/K2) 851/84 MR (K1/K2)
MS (K1/K2) 953/84 MS (K1/K2)
NP 611/84
007-09265-000 007-09266-000 007-09267
NP
007-09857-000 007-09858-000 007-08857-000 007-08858-000
NQ 731/84 NQ
NR 851/84 NR
NS 953/84 NS
PQ 1061/100
007-09262-000 007-09263-000 007-09264-000
PQ
PR 1199/100 PR 007-09859-000 007-09860-000 007-08650-000 007-08641-000
PS 1341/100 PS
QQ 1061/100
007-09265-000 007-09266-000 007-09267-000
QR 1199/100 QR 007-09857-000 007-09858-000 007-08857-000 007-08858-000
QS 1341/100 QS
RQ 1436/120
007-09265-000 007-09266-000 007-09267-000
RQ
RR 1589/120 RR 007-09857-000 007-09858-000 007-08857-000 007-08858-000
RS 1704/120 RS
SQ 1436/120
007-09608-000 007-09626-000 007-09627-000
SQ
SR 1589/120 SR 007-09861-000 007-09862-000 007-09633-000 007-09634-000
SS 1704/120 SS
TP 1567/144
007-09265-000 007-09266-000 007-09267-000
TP
007-09861-000 007-09862-000 007-09633-000 007-09634-000
TQ 1750/144 TQ
TR 1941/144 TR
TS 2053/144 TS
VP 1567/144
007-09608-000 007-09626-000 007-09627-000
VP
007-09861-000 007-09862-000 007-09633-00 007-09634-000
VQ 1750/144 VQ
VR 1941/144 VR
VS 2053/144 VS
CONDENSER TUBES (CONT'D)
TABLE 37 (CONT'D) - 3/4" CONDENSER TUBES
86 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
SHELL
CODE
TUBE
QUANTITY
CONDENSER/
SUB-COOLER
COPPER
SHELL
CODE
TUBE
QUANTITY CONDENSER/
SUB-COOLER
COPPER
STANDARD OPTIONS STANDARD OPTIONS
0.025 (MT260#) 0.028 (MT#261) 0.035 (MT#262) 0.025 (MT260#) 0.028 (MT#261) 0.035 (MT#262)
WQ 1522/180
007-10051-000 007-10052-000 007-10053-000
WQ
WR 1688/180 WR 007-10040-000 007-10041-000 007-10042-000 007-10043-000
WS 1854/180 WS
XQ 1799/180
007-09265-000 007-09266-000 007-09267-000
XQ
XR 2029/180 XR 007-09857-000 007-09858-000 007-08857-000 007-08858-000
XS 2325/180 XS
ZQ 1799/180
007-09608-000 007-09626-000 007-09627-000
ZQ
ZR 2029/180 ZR 007-09857-000 007-09858-000 007-08857-000 007-08858-000
ZS 2325/180 ZS
Table 38 - 3/4" HEAT RECOVERY CONDENSER TUBES
SHELL
CODE
TUBE
QUANTITY
Condenser/
Sub-Cooler
COPPER
SHELL
CODE
COPPER NICKEL COPPER (Smooth Bore)
STANDARD OPTIONS OPTIONS
0.025 (MT#) 0.028 (MT#) 0.035 (MT#) 0.028 (MT#) 0.035 (MT#) 0.028 (MT#) 0.035 (MT#)
BW* 176/NA
007-09289-000 007-09282-000 007-09283-000
BW*
007-08412-000 007-07935-000 007-09200-000 007-08518-000
BX* 273/NA BX*
BW**
395/60
BW**
BX** BX**
IW* 242/NA IW*
IX* 426/NA IX*
IW**
601/72
IW**
IX** IX**
OW* 298/NA
007-09262-000 007-09263-000 007-09264-000
OW*
007-09859-000 007-09860-000 007-08650-000 007-08641-000
OX* 629/NA OX*
OW**
871/121
OW**
OX** OX**
UW* 339/NA
007-09262-000 007-09263-000 007-09264-000
UW*
007-09859-000 007-09860-000 007-08650-000 007-08641-000
UX* 663/NA UX*
UW**
875/169
UW**
UX** UX**
YW* 823/NA
007-09608-000 007-09626-000 007-09627-000
YW*
007-09861-000 007-09862-000 007-09633-000 007-09634-000
YX* 1559/NA YX*
YW**
2802/361
YW**
YX** YX**
NOTE:
* Heating Bundle Tubes
** Main Tower Bundle Tubes / Sub-Cooler Tubes
CONDENSER TUBES (CONT'D)
TABLE 37 (CONT'D) - 3/4" CONDENSER TUBES
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 87
SHELL
CODE
TUBE
QUANTITY
CONDENSER/
SUB-COOLER
COPPER
SHELL
CODE
TUBE
QUANTITY CONDENSER/
SUB-COOLER
COPPER
STANDARD OPTIONS STANDARD OPTIONS
0.025 (MT260#) 0.028 (MT#261) 0.035 (MT#262) 0.025 (MT260#) 0.028 (MT#261) 0.035 (MT#262)
WQ 1522/180
007-10051-000 007-10052-000 007-10053-000
WQ
WR 1688/180 WR 007-10040-000 007-10041-000 007-10042-000 007-10043-000
WS 1854/180 WS
XQ 1799/180
007-09265-000 007-09266-000 007-09267-000
XQ
XR 2029/180 XR 007-09857-000 007-09858-000 007-08857-000 007-08858-000
XS 2325/180 XS
ZQ 1799/180
007-09608-000 007-09626-000 007-09627-000
ZQ
ZR 2029/180 ZR 007-09857-000 007-09858-000 007-08857-000 007-08858-000
ZS 2325/180 ZS
Table 38 - 3/4" HEAT RECOVERY CONDENSER TUBES
SHELL
CODE
TUBE
QUANTITY
Condenser/
Sub-Cooler
COPPER
SHELL
CODE
COPPER NICKEL COPPER (Smooth Bore)
STANDARD OPTIONS OPTIONS
0.025 (MT#) 0.028 (MT#) 0.035 (MT#) 0.028 (MT#) 0.035 (MT#) 0.028 (MT#) 0.035 (MT#)
BW* 176/NA
007-09289-000 007-09282-000 007-09283-000
BW*
007-08412-000 007-07935-000 007-09200-000 007-08518-000
BX* 273/NA BX*
BW**
395/60
BW**
BX** BX**
IW* 242/NA IW*
IX* 426/NA IX*
IW**
601/72
IW**
IX** IX**
OW* 298/NA
007-09262-000 007-09263-000 007-09264-000
OW*
007-09859-000 007-09860-000 007-08650-000 007-08641-000
OX* 629/NA OX*
OW**
871/121
OW**
OX** OX**
UW* 339/NA
007-09262-000 007-09263-000 007-09264-000
UW*
007-09859-000 007-09860-000 007-08650-000 007-08641-000
UX* 663/NA UX*
UW**
875/169
UW**
UX** UX**
YW* 823/NA
007-09608-000 007-09626-000 007-09627-000
YW*
007-09861-000 007-09862-000 007-09633-000 007-09634-000
YX* 1559/NA YX*
YW**
2802/361
YW**
YX** YX**
NOTE:
* Heating Bundle Tubes
** Main Tower Bundle Tubes / Sub-Cooler Tubes
CONDENSER TUBES (CONT'D)
TABLE 37 (CONT'D) - 3/4" CONDENSER TUBES
TABLE 38 (CONT'D) - 3/4" HEAT RECOVERY CONDENSER TUBES
88 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 39 - 1" CONDENSER TUBES
SHELL
CODE
TUBE QUANTITY
CONDENSER/
SUB-COOLER
COPPER COPPER NICKEL
STANDARD OPTIONS
0.025 (MT#266/260) 0.028 (MT#267/261) 0.035 (MT#268/262) 0.028 (MT#317/261)
E3 207/42 007-10442-000/
007-09289-000
007-10443-000/
007-09282-000
007-10444-000/
007-09283-000
007-10449-000/
E4 259/42 007-09282-000
F3 207/42 007-10025-000/
007-09265-000
007-10063-000/
007-09266-000
007-10064-000/
007-09267-000
007-10123-000/
F4 259/42 007-09266-000
K2 235/51
007-10054-000/
007-09262-000
007-10055-000/
007-09263-000
007-10056-000/
007-09264-000
007-10120-000/
007-09263-000 K3 285/51
K4 391/51
M2 301/84
007-10054-000/
007-09262-000
007-10055-000/
007-09263-000
007-10056-000/
007-09264-000
007-10120-000/
007-09263-000 M3 383/84
M4 481/84
N2 301/84
007-10025-000/
007-09265-000
007-10063-000/
007-09266-000
007-10064-000/
007-09267-000
007-10123-000/
007-09266-000 N3 383/84
N4 481/84
P2 470/100
007-10054-000/
007-09262-000
007-10055-000/
007-09263-000
007-10056-000/
007-09264-000
007-10120-000/
007-09263-000 P3 581/100
P4 717/100
Q2 470/100
007-10025-000/
007-09265-000
007-10063-000/
007-09266-000
007-10064-000/
007-09267-000
007-10123-000/
007-09266-000 Q3 581/100
Q4 717/100
R2 621/120
007-10025-000/
007-09265-000
007-10063-000/
007-09266-000
007-10064-000/
007-09267-000
007-10123-000/
007-09266-000 R3 745/120
R4 893/120
S2 621/120
007-10065-000/
007-09608-000
007-1066-000/
007-09626-000
007-10067-000/
007-09627-000
007-10037-000/
007-09626-000 S3 745/120
S4 893/120
T2 670/144
007-10025-000/
007-09265-000
007-10063-000/
007-09266-000
007-10064-000/
007-09267-000
007-10123-000/
007-09266-000
T3 848/144
T4 943/144
T5 1071/144
V2 670/144
007-10065-000/
007-09608-000
007-10066-000/
007-09626-000
007-10067-000/
007-09627-000
007-10037-000/
007-09626-000
V3 848/144
V4 943/144
V5 1071/144
W1 594/180
007-10068-000/
007-10051-000
007-10069-000/
007-1052-0002
007-10070-000/
007-10053-000
007-10124-000/
007-10052-000
W2 757/180
W3 899/180
W4 1003/180
X2 710/180
007-10025-000/
007-09265-000
007-10063-000/
007-09626-000
007-10064-000/
007-09267-000
007-10123-000/
007-09266-000 X3 955/180
X4 1215/180
Z1 576/180
007-10065-000/
007-09608-000
007-10066-000/
007-09626-000
007-10067-000/
007-09627-000
007-10037-000/
007-09626-000
Z2 710/180
Z3 955/180
Z4 1215/180
CONDENSER TUBES (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 89
Table 40 - 1" HEAT RECOVERY CONDENSER TUBES
SHELL
CODE
TUBE
QUANTITY
CONDENSER/
SUB-COOLER
COPPER COPPER NICKEL
STANDARD OPTIONS
0.025 (MT#266/260) 0.028 (MT#267/261) 0.035 (MT#268/262) 0.028 (MT#317/261)
O8*
431/121 007-10054-000/
007-09262-000
007-10055-000/
007-09263-000
007-10056-000/
007-09264-000
007-10120-000/
007-09263-000 O9*
O8** 181/NA 007-10054-000/
007-09262-000
007-10055-000/
007-09263-000
007-10056-000/
007-09264-000
007-10120-000/
007-09263-000 O9** 289/NA
U8*
463/169 007-10054-000/
007-09262-000
007-10055-000/
007-09263-000
007-10056-000/
007-09264-000
007-10120-000/
007-09263-000 U9*
U8** 190/NA 007-10054-000/
007-09262-000
007-10055-000/
007-09263-000
007-10056-000/
007-09264-000 007-10120-000
U9** 305/NA
Y8*
1101/361 007-10065-000/
007-09608-000
007-10066-000/
007-09626-000
007-10067-000/
007-09627-000
007-10037-000/
007-09626-000 Y9*
Y8** 522/NA 007-10065-000/
007-09608-000
007-10066-000/
007-09626-000
007-10067-000/
007-09627-000 007-10037-000
Y9** 846/NA
NOTE:
* Heating Bundle Tubes
** Main Tower Bundle Tubes / Sub-Cooler Tubes
CONDENSER TUBES (CONT'D)
90 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
WATERBOX GASKETS
Table 41 - CONDENSER COMPACT WATERBOXES 150 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
AP-AS 028-09951-000 11.5" 028-09951-000 13.5' 028-09951-000 15'
CP-CS
028-09951-000 13.5' 028-09951-000 15.5' 028-09951-000 17.5'
DP-DS
EP-EX
028-09951-000 15.5' 028-09951-000 17.9' 028-09951-000 20.3'
FQ-FX
JP-JS
KP-KS 028-09951-000 17.6' 028-09951-000 20.4' 028-09951-000 23'
LQ-LS
K2-K4
028-09951-000 21' 028-09951-000 24' 028-09951-000 27'
MP-MS
M2-M4
NP-NS
N2-N4
PQ-PS
028-09951-000 24' 028-09951-000 28' 028-09951-000 32'
P2-P4
QQ-QS
Q2-Q4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
1-PASS 2-PASS 3-PASS
Figure 40 - CONDENSER 150 LB. WATERBOX GASKET
LD13068
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 91
TABLE 41 (CONT'D) - CONDENSER COMPACT WATERBOXES 150 PSI
WATERBOX GASKETS (CONT'D)
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
RQ-RS
028-03242-000 26.4' 028-09951-000
028-03242-000
4'
26.4'
028-09951-000
028-03242-000
7.5'
26.4'
R2-R4
SQ-SS
S2-S4
TP-TS
028-03242-000 28' 028-09951-000
028-03242-000
4.4'
28'
028-09951-000
028-03242-000
8.6'
28'
T2-T5
VP-VS
V2-V5
WQ-WS
W1-W4
XQ-XS
028-03242-000 30' 028-09951-000
028-03242-000
4.7'
30'
028-09951-000
028-03242-000
9.2'
30'
X2-X3
ZQ-ZS
Z1-Z4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 41 - CONDENSER 150 LB. WATERBOX GASKET
LD13148
1-PASS 2-PASS 3-PASS
92 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
WATERBOX GASKETS (CONT'D)
Table 42 - CONDENSER COMPACT WATERBOXES 150 PSI (PRIOR JULY 2010)
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
AP-AS 028-03242-000 11.4' 028-09951-000
028-03242-000
1.8'
11.4'
028-09951-000
028-03242-000
1.8'
11.4'
CP-CS
028-03242-000 13.5' 028-09951-000
028-03242-000
2.1'
13.5'
028-09951-000
028-03242-000
4.1'
13.5' DP-DS
EP-EX
028-03242-000 15.8' 028-09951-000
028-03242-000
2.5'
15.8'
028-09951-000
028-03242-000
4.8'
FQ-FX 15.8'
JP-JS
028-03242-000 17.8' 028-09951-000
028-03242-000
2.8'
17.8'
028-09951-000
028-03242-000
5.4'
17.8' KP-KS
LQ-LS
MP-MS
028-03242-000 21.5' 028-09951-000
028-03242-000
4'
21.5'
028-09951-000
028-03242-000
7'
21.5'
M2-M4
NP-NS
N2-N4
PQ-PS
028-03242-000 24' 028-09951-000
028-03242-000
4'
24'
028-09951-000
028-03242-000
8'
24'
P2-P4
QQ-QS
Q2-Q4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 42 - CONDENSER 150 LB. WATERBOX GASKET
LD13070
1-PASS 2-PASS 3-PASS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 93
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
RQ-RS
028-03242-000 25.8' 028-09951-000
028-03242-000
4'
25.8'
028-09951-000
028-03242-000
7.9'
25.8'
R2-R4
SQ-SS
S2-S4
TP-TS
028-03242-000 28.1' 028-09951-000
028-03242-000
4.4'
28.1'
028-09951-000
028-03242-000
8.5'
28.1'
T2-T5
VP-VS
V2-V5
WQ-WS
W1-W4
ZQ-ZS
028-03242-000 30' 028-09951-000
028-03242-000
5.1'
30'
028-09951-000
028-03242-000
5.1'
Z1-Z4 30'
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 43 - CONDENSER 150 LB. WATERBOX GASKET
LD13070
1-PASS 2-PASS 3-PASS
TABLE 42 (CONT'D) - CONDENSER COMPACT WATERBOXES 150 PSI (PRIOR JULY 2010)
WATERBOX GASKETS (CONT'D)
94 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 43 - EVAPORATOR WITH STANDARD COMPACT WATERBOXES 150 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
AP-AS 028-09951-000 13.5' 028-09951-000 15.5' 028-09951-000 17.5'
CP-CS
028-09951-000 15.6' 028-09951-000 18.1' 028-09951-000 20.1'
DP-DS
EP-ET
028-09951-000 17.6' 028-09951-000 20.6' 028-09951-000 22.8'
FQ-FS
GQ-GS
028-09951-000 20.6' 028-09951-000 24.4' 028-09951-000 27.1'
HQ-HS
JP-JS
KP-KX 028-09951-000 23.3' 028-09951-000 31' 028-09951-000 30'
LQ-LS
K2-K7 - - - - 028-09951-000 30'
MQ-MS
028-03242-000 27' 028-09951-000
028-03242-000
5.5'
27'
028-09951-000
028-03242-000
5.5'
27'
M2-M4
NQ-NS
N2-N4
PQ-PS
028-03242-000 27' 028-09951-000
028-03242-000
5.5'
27'
028-09951-000
028-03242-000
5.5'
27'
P2-P4
QQ-QS
Q2-Q4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 44 - EVAPORATOR 150 LB. WATERBOX GASKET
LD13151
1-PASS 2-PASS 3-PASS
WATERBOX GASKETS (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 95
TABLE 43 (CONT'D) - EVAPORATOR WITH STANDARD COMPACT WATERBOXES 150 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
QT-QV 028-03242-000 26' 028-09951-000
028-03242-000
6'
26'
028-09951-000
028-03242-000
8.5'
26'
RQ-RV
028-03242-000 15.9' 028-09951-000
028-03242-000
5.5'
15.9'
028-09951-000
028-03242-000
5.5'
15.9'
R2-R7
SQ-SV
S3-S7
WP-WT
W1-W6
XQ-XS
028-03242-000 15.9' 028-09951-000
028-03242-000
5.5'
15.9'
028-09951-000
028-03242-000
5.5'
15.9'
X2-X4
ZQ-ZS
Z1-Z4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 45 - EVAPORATOR 150 LB. WATERBOX GASKET
LD13070
1-PASS 2-PASS 3-PASS
WATERBOX GASKETS (CONT'D)
96 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 44 - EVAPORATOR WITH STANDARD COMPACT WATERBOXES 300 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
AP-AS 028-03242-000 13.7' 028-09951-000
028-03242-000
2.2'
13.7'
028-09951-000
028-03242-000
3.9'
13.7'
CP-CS
028-03242-000 17.9' 028-09951-000
028-03242-000
3'
17.9'
028-09951-000
028-03242-000
5.8'
DP-DS 17.9'
EP-ET
028-03242-000 20.8' 028-09951-000
028-03242-000
3.7'
20.8'
028-09951-000
028-03242-000
6.5'
FQ-FT 20.8'
GQ-GS
028-03242-000 23.8' 028-09951-000
028-03242-000
13.5'
23.8'
028-09951-000
028-03242-000
6.7'
HQ-HS 23.8'
JP-JS
028-03242-000 26' 028-09951-000
028-03242-000
4.5'
26'
028-09951-000
028-03242-000
8'
26'
KP-KX
LQ-LS
K2-K7 - - - - 028-09951-000
028-03242-000
6.7'
23.8'
MQ-MS
028-03242-000 28' 028-09951-000
028-03242-000
5'
28'
028-09951-000
028-03242-000
8'
28'
M2-M4
NQ-NS
N2-N4
PQ-PS
028-03242-000 32.5' 028-09951-000
028-03242-000
5.5'
32.5'
028-09951-000
028-03242-000
5.5'
32.5'
P2-P4
QQ-QV
Q2-Q4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
1-PASS 2-PASS 3-PASS
Figure 46 - EVAPORATOR 300 LB. WATERBOX GASKET
LD13149
WATERBOX GASKETS (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 97
TABLE 44 (CONT'D) - EVAPORATOR WITH STANDARD COMPACT WATERBOXES 300 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
RQ-RV
028-03242-000 32.5' 028-09951-000
028-03242-000
5.5'
32.5'
028-09951-000
028-03242-000
5.5'
32.5'
R2-R7
SQ-SV
S3-S7
WP-WT
W1-W6
XQ-XS
028-03242-000 32.5' 028-09951-000
028-03242-000
5.5'
32.5'
028-09951-000
028-03242-000
10'
32.5'
X2-X4
ZQ-ZS
Z1-Z4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 47 - EVAPORATOR 300 LB. WATERBOX GASKET
LD13150
1-PASS 2-PASS 3-PASS
WATERBOX GASKETS (CONT'D)
98 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 45 - CONDENSER WITH MARINE WATERBOXES 150 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
AP-AS 028-09951-000 22.7' 028-09951-000 20.7' 028-09951-000 20.7'
CP-CS
02809951-000 27.2' 028-09951-000 27.2' 028-09951-000 35.4'
DP-DS
EP-ET
028-09951-000 31' 028-09951-000 28.2' 028-09951-000 40.6'
FP-FS
JP-JS
028-09951-000 35.2' 028-09951-000 32' 028-09951-000 41'
KP-KS
K2-K4
LQ-LS
MP-MS
028-03242-000 42' 028-09951-000
028-03242-000
17'
21'
028-09951-000
028-03242-000
13'
42'
M2-M4
NP-NS
N2-N4
MB-MH - - 028-09951-001
028-03242-000
17'
31.5'
028-09951-001
028-03242-000
13'
NB-NH 42'
PQ-PS
028-03242-000 47' 028-09951-000
028-03242-000
8'
47'
028-09951-000
028-03242-000
15'
47'
P2-P4
QQ-QS
Q2-Q4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 48 - CONDENSER 150 LB. MARINE WATERBOX GASKET LD13153
1-PASS 2-PASS 3-PASS
WATERBOX GASKETS (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 99
TABLE 45 (CONT'D) - CONDENSER WITH MARINE WATERBOXES 150 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
RQ-RS
028-03242-000 52.8' 028-09951-000
028-03242-000
8'
39.6'
028-09951-000
028-03242-000
8'
39.6'
R2-R4
SQ-SS
S2-S4
TP-TS
028-03242-000 55.7' 028-09951-000
028-03242-000
8.7'
41.8'
028-09951-000
028-03242-000
8.7'
41.5'
T2-T5
VP-VS
V2-V5
WQ-WS
W1-W4
XQ-XS
028-03242-000 60' 028-09951-000
028-03242-000
24.5'
30.5'
028-09951-000
028-03242-000
18.5'
X1-X4 60'
ZQ-ZS
028-03242-000 55.3' 028-09951-000
028-03242-000
9.4'
41.5'
028-09951-000
028-03242-000
18.5'
Z1-Z4 55.3'
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 49 - CONDENSER 150 LB. MARINE WATERBOX GASKET
LD13154
WATERBOX GASKETS (CONT'D)
100 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 46 - CONDENSER WITH MARINE WATERBOXES 300 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
AP-AS 028-03242-000 23.2' 028-09951-000
028-03242-000
3.6'
17.4'
028-09951-000
028-03242-000
7'
23.2'
CP-CS
028-03242-000 27.4' 028-09951-000
028-03242-000
2.1'
20.7'
028-09951-000
028-03242-000
4.1'
DP-DS 27.4'
EP-ET
028-03242-000 31.6' 028-09951-000
028-03242-000
4.9'
23.6'
028-09951-000
028-03242-000
9.5'
FQ-FT 32'
EV-E4 - - 028-09951-000
028-03242-000
4.9'
23.6'
028-09951-000
028-03242-000
9.5'
FV-F4 32'
JP-JS
028-03242-000 35.6' 028-09951-000
028-03242-000
2.7'
26.7'
028-09951-000
028-03242-000
5.4'
35.6'
KP-KS
K2-K4
LQ-LS
MP-MS
028-03242-000 42.75' 028-09951-000
028-03242-000
6.5'
32'
028-09951-000
028-03242-000
13'
43'
M2-M4
NP-NS
N2-N4
PQ-PS
028-03242-000 47' 028-09951-000
028-03242-000
8'
47'
028-09951-000
028-03242-000
15'
47'
P2-P4
QQ-QV
Q2-Q4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 50 - CONDENSER 300 LB. MARINE WATERBOX GASKET
1-PASS 2-PASS 3-PASS LD13153
WATERBOX GASKETS (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 101
TABLE 46 (CONT'D) - CONDENSER WITH MARINE WATERBOXES 300 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
RQ-RS
028-03242-000 51.5' 028-09951-000
028-03242-000
8'
39'
028-09951-000
028-03242-000
16'
51.5'
R2-R4
SQ-SS
S2-S4
TP-TS
028-03242-000 56' 028-09951-000
028-03242-000
9.4'
42'
028-09951-000
028-03242-000
18.2'
60.1'
T2-T5
VP-VS
V2-V5
WQ-WS
W1-W4
ZQ-ZS
028-03242-000 60.1' 028-09951-000
028-03242-000
9.4'
45.1'
028-09951-000
028-03242-000
18.2'
Z1-Z4 60.1'
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 51 - CONDENSER 300 LB. MARINE WATERBOX GASKET
LD13154
1-PASS 2-PASS 3-PASS
WATERBOX GASKETS (CONT'D)
102 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 47 - EVAPORATOR WITH MARINE WATERBOXES 150 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
AP-AS 028-09951-000 27' 028-09951-000 24.8' 028-09951-000 35.8'
CP-CS
028-09951-000 31.1' 028-09951-000 27.6' 028-09951-000 39'
DP-DS
EP-ET
028-09951-000 35.2' 028-09951-000 32.2' 028-09951-000 47'
FQ-FT
GQ-GS
028-03242-000 41.8' 028-09951-000
028-03242-000
7.1'
31.4'
028-09951-000
028-03242-000
12.8'
HQ-HS 41.8'
JP-JS
028-03242-000 47' 028-09951-000
028-03242-000
19'
24'
028-09951-000
028-03242-000
27'
47'
KP-KX
K2-K7
LQ-LS
MQ-MS
028-03242-000 52' 028-09951-000
028-03242-000
8'
39'
028-09951-000
028-03242-000
15'
52'
M2-M4
NQ-NS
N2-N4
PQ-PS
028-03242-000 56' 028-09951-000
028-03242-000
18'
56'
028-09951-000
02803242-000
18'
56'
P2-P4
QQ-QV
Q2-Q4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 52 - EVAPORATOR 150 LB. MARINE WATERBOX GASKET
LD13157
1-PASS 2-PASS 3-PASS
WATERBOX GASKETS (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 103
TABLE 47 (CONT'D) - EVAPORATOR WITH MARINE WATERBOXES 150 PSI (CONT'D)
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
RQ-RV
028-03242-000 56' 028-09951-000
028-03242-000
18'
56'
028-09951-000
028-03242-000
24'
56'
R2-R7
SQ-SV
S3-S7
WP-WT
W1-W6
XQ-XS
028-03242-000 66.3' 028-09951-000
028-03242-000
11.2'
49.8'
028-09951-000
028-03242-000
19.4'
66.3'
X2-X4
ZQ-ZS
Z1-Z4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 53 - EVAPORATOR 150 LB. MARINE WATERBOX GASKET
LD13158
1-PASS 2-PASS 3-PASS
WATERBOX GASKETS (CONT'D)
104 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 48 - EVAPORATOR WITH MARINE WATERBOXES 300 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
AP-AS 028-03242-000 56' 028-09951-000
028-03242-000
4.4'
22'
028-09951-000
028-03242-000
7.8'
29.2'
CP-CS
028-03242-000 31.6' 028-09951-000
028-03242-000
5.1'
23.6'
028-09951-000
028-03242-000
8.9'
DP-DS 32'
EP-ET
028-03242-000 35.8' 028-09951-000
028-03242-000
3.4'
26.4'
028-09951-000
028-03242-000
11.6'
FQ-FT 35.8'
GQ-GS
028-03242-000 42.7' 028-09951-000
028-03242-000
7.4'
32.1'
028-09951-000
028-03242-000
12'
HQ-HS 42.7'
JP-JS
028-03242-000 47.6' 028-09951-000
028-03242-000
7.6'
35.7'
028-09951-000
028-03242-000
13.4'
47.6'
KP-KX
K2-K7
LQ-LS
MQ-MS
028-03242-000 52' 028-09951-000
028-03242-000
8.5'
39'
028-09951-000
028-03242-000
15'
52'
M2-M4
NQ-NS
N2-N4
PQ-PS
028-03242-000 56' 028-09951-000
028-03242-000
9'
42'
028-09951-000
028-03242-000
16'
52'
P2-P4
QQ-QV
Q2-Q4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 54 - EVAPORATOR 300 LB. MARINE WATERBOX GASKET LD13159
1-PASS 2-PASS 3-PASS
WATERBOX GASKETS (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 105
TABLE 48 (CONT'D) - EVAPORATOR WITH MARINE WATERBOXES 300 PSI (CONT'D)
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
RQ-RV
028-03242-000 56' 028-09951-000
028-03242-000
9'
42'
028-09951-000
028-03242-000
16'
52'
R2-R7
SQ-SV
S3-S7
WP-WT
W1-W6
XQ-XS
028-03242-000 65' 028-09951-000
028-03242-000
11'
48.7' 028-09951-000 65'
X2-X4
ZQ-ZS
Z1-Z4
NOTE: When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
Figure 55 - EVAPORATOR 300 LB. MARINE WATERBOX GASKET
LD13160
1-PASS 2-PASS 3-PASS
WATERBOX GASKETS (CONT'D)
106 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 49 - CONDENSER WITH HEAT RECOVERY COMPACT WATERBOXES 150 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
BW, BX* 028-03242-000 18.5' 028-09951-000
028-03242-000
3.5'
18.5'
028-09951-000
028-03242-000
6'
18.5'
BW, BX** 028-03242-000 17.5' 028-09951-000
028-03242-000
3.5'
17.5'
028-09951-000
028-03242-000
6'
17.5'
IW, IX* 028-03242-000 21' 028-09951-000
028-03242-000
4'
21'
028-09951-000
028-03242-000
7'
21'
IW, IX** 028-03242-000 19.5' 028-09951-000
028-03242-000
4'
19.5'
028-09951-000
028-03242-000
7'
19.5'
OW, OX
O8, O9* 028-03242-000 24.5' 028-09951-000
028-03242-000
4.5'
24.5'
028-09951-000
028-03242-000
8'
24.5'
OW, OX
O8, O9** 028-03242-000 22.5' 028-09951-000
028-03242-000
4.5'
22.5'
028-09951-000
028-03242-000
8'
22.5'
UW, UX
U8, U9* 028-03242-000 26' 028-09951-000
028-03242-000
5'
26'
028-09951-000
028-03242-000
8.5'
26'
UW, UX
U8, U9** 028-03242-000 24.5' 028-09951-000
028-03242-000
4.5'
24.5'
028-09951-000
028-03242-000
8.5'
24.5'
YW, YX
Y8, Y9* 028-03242-000 37' 028-09951-000
028-03242-000
7'
37'
028-09951-000
028-03242-000
12'
37'
YW, YX
Y8, Y9** 028-03242-000 33' 028-09951-000
028-03242-000
6.5'
33'
028-09951-000
028-03242-000
12'
33'
NOTE:
* Cooling Only Waterbox Arrangement
**Heat Recovery Waterbox Arrangement
When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
1-PASS 2-PASS 3-PASS
Figure 56 - CONDENSER HEAT RECOVERY 150 LB. WATERBOX GASKET
LD13823
WATERBOX GASKETS (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 107
Table 50 - CONDENSER WITH HEAT RECOVERY COMPACT WATERBOXES 300 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
BW, BX* 028-03242-000 18.5' 028-09951-000
028-03242-000
3.5'
18.5'
028-09951-000
028-03242-000
6'
18.5'
BW, BX** 028-03242-000 17.5' 028-09951-000
028-03242-000
3.5'
17.5'
028-09951-000
028-03242-000
6'
17.5'
IW, IX* 028-03242-000 21' 028-09951-000
028-03242-000
4'
21'
028-09951-000
028-03242-000
7'
21'
IW, IX** 028-03242-000 19.5' 028-09951-000
028-03242-000
4'
19.5'
028-09951-000
028-03242-000
7'
19.5'
OW, OX
O8, O9* 028-03242-000 24.5' 028-09951-000
028-03242-000
4.5'
24.5'
028-09951-000
028-03242-000
8'
24.5'
OW, OX
O8, O9** 028-03242-000 22.5' 028-09951-000
028-03242-000
4.5'
22.5'
028-09951-000
028-03242-000
8'
22.5'
UW, UX
U8, U9* 028-03242-000 26' 028-09951-000
028-03242-000
5'
26'
028-09951-000
028-03242-000
8.5'
26'
UW, UX
U8, U9** 023-03242-000 24.5' 028-09951-000
028-03242-000
4.5'
24.5'
028-09951-000
028-03242-000
8.5'
24.5'
YW, YX
Y8, Y9* 023-03242-000 37' 028-09951-000
028-03242-000
7'
37'
028-09951-000
028-03242-000
12'
37'
YW, YX
Y8, Y9** 023-03242-000 33' 028-09951-000
028-03242-000
6.5'
33'
028-09951-000
028-03242-000
12'
33'
NOTE:
* Cooling Only Waterbox Arrangement
**Heat Recovery Waterbox Arrangement
When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
1-PASS 2-PASS 3-PASS
Figure 57 - CONDENSER HEAT RECOVERY 300 LB. WATERBOX GASKET
LD13824
WATERBOX GASKETS (CONT'D)
108 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 51 - CONDENSER WITH HEAT RECOVERY MARINE WATERBOXES 150 PSI
SHELL
CODE
1 PASS 2 PASS 3 PASS
GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED GASKET P/N FEET
REQUIRED
BW, BX* 028-03242-000 18.5' 028-09951-000
028-03242-000
3.5'
18.5'
028-09951-000
028-03242-000
6'
18.5'
BW, BX** 028-03242-000 19.5' 028-09951-000
028-03242-000
3'
19.5'
028-09951-000
028-03242-000
5'
19.5'
IW, IX* 028-03242-000 21' 028-09951-000
028-03242-000
4'
21'
028-09951-000
028-03242-000
7'
21'
IW, IX** 028-03242-000 21' 028-09951-000
028-03242-000
4'
21'
028-09951-000
028-03242-000
6.5'
21'
OW, OX
O8, O9* 028-03242-000 24.5' 028-09951-000
028-03242-000
4.5'
24.5'
028-09951-000
028-03242-000
8'
24.5'
OW, OX
O8, O9** 028-03242-000 24.5' 028-09951-000
028-03242-000
4.5'
24.5'
028-09951-000
028-03242-000
8'
24.5'
UW, UX
U8, U9* 028-03242-000 26' 028-09951-000
028-03242-000
5'
26'
028-09951-000
028-03242-000
8.5'
26'
UW, UX
U8, U9** 028-03242-000 25.5' 028-09951-000
028-03242-000
4.5'
25.5'
028-09951-000
028-03242-000
7.5'
25.5'
YW, YX
Y8, Y9* 028-03242-000 37' 028-09951-000
028-03242-000
7'
37'
028-09951-000
028-03242-000
12'
37'
YW, YX
Y8, Y9** 028-03242-000 37' 028-09951-000
028-03242-000
5'
37'
028-09951-000
028-03242-000
12'
37'
NOTE:
* Cooling Only Waterbox Arrangement
**Heat Recovery Waterbox Arrangement
When ordering Gasket Material specify length required by replacing the -000 with either -025 for 25', -050 for 50', or -100 for 100'.
MARINE
WATERBOX
COMPACT
WATERBOX
MAIN
BUNDLE
HEAT
RECOVERY
BUNDLE
Figure 58 - CONDENSER MARINE HEAT RECOVERY 150 LB. WATERBOX GASKET
LD13823
WATERBOX GASKETS (CONT'D)
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 109
Table 52 - NEOPRENE VIBRATION ISOLATORS
SYSTEM OPERATING WEIGHT PART NUMBER
(Includes Quantity of 4 Pads) PAD SIZE
KILOGRAMS POUNDS
Up to 7423 Up to 16,365 028-14462-000 5.5" x 5.5" (14 x 14 cm)
7424 to 13,107 16,366 to 28,835 028-14459-000 7" x 5.5" (23 x 14 cm)
13,108 to 24,332 28,836 to 53,530 028-14460-000 9" x 7" (23 x 18 cm)
24,333 to 45,666 53,531 to 100,464 028-14461-000 11" x 10" (30 x 25.4 cm)
45,667 to 58,967 100,465 to 130,000 028-15070-000 12" x 11" (30.5 x 30 cm)
58,968 to 91,332 130,001 to 200,928 028-14461-000* 11" x 10" (30 x 25.4 cm)
NOTE: * When used with K7. Quantity is 2.
Table 53 - SPRING ISOLATORS
SYSTEM OPERATING WEIGHT PART NUMBER
(Includes Quantity 4 Spring Bolts)
QUANTITY
KILOGRAMS POUNDS (Number of Mounts Per Package)
4536 to 8873 10,000 to 19,563 029-23716-000 4
8874 to 11,093 19,564 to 24,457 029-21793-000 4
11,094 to 13,982 24,458 to 30,826 029-21376-000 4
13,983 to 15,880 30,827 to 35,009 029-20933-000 4
15,881 to 20,974 35,010 to 46,239 029-20934-000 4
20,975 to 26,467 46,240 to 58,349 029-20935-000 4
26,468 to 35,031 58,350 to 77,229 029-20936-000 4
35,032 to 40,525 77,230 to 89,340 029-21388-000 4
40,526 to 52,163 89,341 to 115,000 029-24121-000 4
52,164 to 86,183 115,001 to 190,000 029-24384-000 4
LD13057
Figure 59 - NEOPRENE ISOLATORS / SPRING ISOLATORS
SHELL
SHELL
END SHEET
END
SHEET
CAP
SCREW
ADJUSTING
BOLT
NEOPRENE ISOLATORS SPRING ISOLATORS
VIBRATION ISOLATORS
110 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
Table 54 - INLET CHILLED WATER STRAINER (COMPACT HEADS AND MARINE WATERBOXES)
NOZZLE SIZE PART NUMBER
6 029-12948-000
8 029-12949-000
10 029-12950-000
12 029-12951-000
14 029-14727-000
16 029-14811-000
18 029-20932-000
20 029-22729-000
Table 55 - CURRENT TRANSFORMER KIT AND TRANSFORMER ONLY
USE WITH FACTORY-MOUNTED MOTORS ONLY
USE WITH FIELD INSTALLED ELECTRO-MECHANICAL STARTERS ONLY
MOTOR
VOLTAGE FLA "CT" RATIO
PART NUMBER
TRANSFORMER KIT
(Includes Transformer) TRANSFORMER ONLY
200/600
65-111 200:1 375-17422-701 025-29469-000
112-224 350:1 375-17422-702 025-21173-002
225-829 700:1 375-17422-703 025-21173-003
830-1790 1400:1 375-17422-704 025-21173-004
2300-4160
11-37 200:1 375-17422-705 025-29469-000
124-264 350:1 375-17422-706 025-21173-002
265-518 700:1 375-17422-707 025-21173-005
519-1036 1400:1 375-17422-708 025-21173-011
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 111
TWO UNIT
ITEM DESCRIPTION PART NUMBER QUANTITY
11 Controller, RWT 025-15154-000 1
2 Relay, Time Delay 024-13711-000 1
3 Switch, Toggle 024-14057-000 1
1
Not Shown. Remote Mounted.
THREE UNIT
ITEM DESCRIPTION PART NUMBER QUANTITY
2 Control, Temp 2 Stage 025-10215-000 1
3 Relay, TD 115V 024-30497-000 2
4 Relay, Control 120V Coil 024-14519-000 2
5 Relay Assy. 375-21706-000 1
8 Switch, Toggle 3 Position 024-17026-000 1
18 Switch, Toggle 024-11736-000 1
FOUR UNIT
ITEM DESCRIPTION PART NUMBER QUANTITY
2 Control, Temp. 3-Stage 025-10214-000 1
3 Relay, TD 115V 024-30497-000 3
4 Relay Assy. 375-21706-000 1
5 Relay, Control 120V Coil 024-14519-000 8
8 Switch, Toggle 024-11736-000 1
11 Switch, Rotary 4 Ckt 15A 024-20494-000 1
MULTIPLE UNIT SEQUENCE KIT CONTROLS
Table 56 - MULTIPLE UNIT SEQUENCE KIT (TWO UNIT)
Table 57 - MULTIPLE UNIT SEQUENCE KIT (THREE UNIT)
Table 58 - MULTIPLE UNIT SEQUENCE KIT (FOUR UNIT)
112 JOHNSON CONTROLS
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
MISCELLANEOUS AND ACCESSORIES
Table 59 - CONSUMABLES
DESCRIPTION PART NUMBER QUANTITY
Compound, Heat Conductive (For Thermometer Wells) 013-00898-000 4 Oz. Can
Caribbean Blue Enamel, Touch-up Spray Can 013-01835-000 -
Black, Touch-up Spray Can Purchase Locally -
YORK "K" Oil (5 Gallon) 011-00533-000 5 Gallon
YORK "K" Oil (R-134a Units) 1 Gallon 011-01202-000 1 Gallon
Table 60 - FLOW SWITCH CONTROL
DESCRIPTION PART NUMBER
150 DWP 024-26116-000
300 DWP 024-12144-000
Table 61 - DIFFERENTIAL PRESSURE CONTROL
DESCRIPTION PART NUMBER
Control, Differential Pressure* 025-30919-000
* 300 PSI Maximum Working Pressure
Table 62 - TEMPERATURE RECORDER
DESCRIPTION
PART NUMBER
HZ NUMBER OF PENS
60
1
2
025-09658-000
025-09823-000
50
1
2
025-12650-000
025-12330-000
Table 63 - COMMON PIPING PARTS
DESCRIPTION STEEL TUBING STAINLESS
STEEL TUBING NUT STEEL SLEEVE STAINLESS
STEEL SLEEVE
3/8" 003-00969-000 003-02407-000 023-18977-000 023-20760-000 023-17534-000
1/2" 003-00243-000 023-17541-000 023-19089-000 023-17542-000
3/4" 003-03518-000 003-02487-017 023-18286-000 023-18914-000 023-17536-000
1" 003-03515-000 023-18287-000 023-18911-000 023-17538-000
FORM 160.75-RP1
ISSUE DATE: 11/15/2013
JOHNSON CONTROLS 113
MISCELLANEOUS AND ACCESSORIES (CONT'D)
Table 64 - ELECTRICAL CONNECTORS
DESCRIPTION YORK P/N
Flow Sensor, (Style F) 025-38186-000
Flow Sensor, 90° Connector (Style G) 025-42799-000
Flow Sensor, Straight (Style G) 025-41574-000
Variable Orifice Actuator- DIN Connector 025-37878-000
Hot Gas Bypass Valve Actuator- DIN Connector 025-37877-000
Oil Return Solenoid- DIN Connector 025-37876-000
Thrust Bearing Proximity Probe- DIN Connector (Style F) 025-34047-000
Thrust Bearing Proximity Probe- DIN Connector (Style G) 025-37805-000
Compressor Stall Sensor- DIN Connector 025-37805-000
Liquid Refrigerant level Sensor- DIN Connector 025-37805-000
PRV Actuator Connector 025-38172-000
VGD Actuator Connector 025-38172-000
Table 65 - RECOMMENDED SPARES
ITEM DESCRIPTION PART NUMBER
1 Preventive Maintenance Kit (YK G Unit) 366-94952-016
Element Oil Filter 026-32831-000
O-Ring Neo1 03.484Id .139Thk M (Oil Filter) 028-14404-000
Filter Drier 3/8 Orfs 026-37563-000
O-Ring Neo1 00.364Id .070Thk M (Filter Drier) 028-12961-012
2
Type F Oil (R-22 Units), 5 Gallons 011-00434-000
Type K Oil (R-134a Units), 5 Gallons 011-00533-000
Type K Oil (R-134a Units), 1 Gallon 011-01202-000
Type J Oil (K Compressor retrofit R-22 to R-134a), 5 Gallons 011-00558-000
NOTE: Reference SI0135 for more information on recommended oil viscosities for R-134a single stage compressors.
Table 66 - AUTOGREESER KIT
DESCRIPTION MICROBOARD SOFTWARE VERSION YORK P/N
Autogreaser
031-02430-000 / -001
older than V27 026-41276-000
V27 and newer 026-47498-000
031-03630-000 V0 and newer 026-47498-000
P.O. Box 1592, York, Pennsylvania USA 17405-1592 Subject to change without notice. Printed in USA
Copyright © by Johnson Controls 2013 ALL RIGHTS RESERVED
Form 160.75-RP1 (113)
Issue Date: November 15, 2013
Supersedes: 160.75-RP1 (411)
Tele. 800-861-1001
www.johnsoncontrols.com